Documentos de Académico
Documentos de Profesional
Documentos de Cultura
1. Title page
2. Declaration
3. Certificate
4. Acknowledgement
5. Abstract
6. List of abbreviations
7. List of fig with page numbers
8. List of tables with page numbers
9. Table of contents with page numbers
10. Chapters
11. Bibliography or list of references
Size: Standard paper size A4 should be used.
Page number: Page should be numbered consecutively and clearly. No page number should be
indicated on title page, supervisors certificates, declaration and acknowledgement, however
pages are to counted from title page. From title page to table of contents with page numbers
page Greek numbers (eg i, ii, iv, x) should be used. From main text to end of thesis Indian
numerals (eg1, 2, 3) should be used. All typing should be on right hand pages only.
Margin: Top 1.0, Bottom 1.0, Left 1.50/1.20 & Right 1.0
Header: There should be header on all pages starting from chapter (after table of contents)
having name of the project.
Footer: There should be footer on all pages starting from chapter (after table of contents)
having DEPARTMENT OF MECHANICAL ENGINEERING, RKGIT
Line spacing: 1.5
Font: Times new roman, size 12 for text. 14 size font with bold for headings & subheadings.
Folded diagram/charts: These should be arranged so as to open to the top and right.
Landscape chart/ fig: Bottom of chart/ figure should be on right side.
Text: Before producing the final copies of a project report the candidate should ensure that all
the spelling, grammar, punctuation and bibliography is complete and exact. And
A
Project Report
On
*Title of the Report
A Project Report Submitted
In The Partial Fulfillment of the Award of the Degree of
BACHELOR OF TECHNOLOGY
MECHANICAL ENGINEERING
Guide Name
By
Student Name
xxxxxxx
Roll No.
xxxxxx
xxxxxx
xxxxxx
xxxxxx
xxxxx
xxxxx
xxxxx
A
Project Report
On
*Title of Project
A Project Report Submitted
In the Partial Fulfillment of the Award of the Degree of
BACHELOR OF TECHNOLOGY
Mechanical Engineering,
2011-2015
by
Name (Roll No.)
Guided by
*GUIDE NAME
*ASSISTANT / ASSOCIATE PROFESSOR
DEPTARTMENT OF MECHANICAL ENGINEERING
RAJ KUMAR GOEL INSTITUTE OF TECHNOLOGY, AKTU
GHAZIABAD, INDIA
DECLARATION
I/We, hereby declare that this submission is my/our own work and that, to
the best of my knowledge and belief is being presented in the project entitled
Date:
Name of Student
Roll No.
Dept of Mechanical Engineering
RKGIT, AKTU
Name of Student
Roll No.
Dept of Mechanical Engineering
RKGIT, AKTU
Name of Student
Roll No.
Dept of Mechanical Engineering
RKGIT, AKTU
Name of Student
Roll No.
Dept of Mechanical Engineering
RKGIT, AKTU
CERTIFICATE
Date:
Guide Name
Designation
Department of Mechanical Engineering
Raj Kumar Goel Institute of Technology
Ghaziabad, India
All the references should be arranged alphabetically or serially as the case may
be for quoting in text.