Documentos de Académico
Documentos de Profesional
Documentos de Cultura
constructive solutions
Properties
Flexibility (BS3416):
Advantages
1.17
1.29
o
4-8 hours at 20 C for
thickness up to 0.5 mm.
Drying times will be longer
for lower temperature and
higher thicknesses.
Pass
Asbestos free.
Surface preparation
Single component.
Preparation of surfaces prior to application of either
Nitoproof 120 or 130 is important. Surface must be clean
and dry and all loosely adhering particles such as rust mill
scale mortar, cement laitence, should be carefully
removed by wire or stiff brushing and finally soft brushing
to remove dust.
to
most
common
building
Application
General
Nitoproof 120 can be applied by brush, roller or spray
equipment.
Nitoproof 130 can be applied by steel trowel.
Standards compliance
Chemical resistance
Page 1
37oC
o
37 C
o
37 C
Nitoproof 120:
Nitoproof 130:
Fosroc Solvent 103:
Spillage
Replace lid when not in use.
sand or sawdust.
Packaging
Nitoproof 120:
Nitoproof 130:
Fosroc Solvent 103:
Coverage
Nitoproof 120 normally 1.5 - 2.5 m2 per litre depending on
film build required.
Cleaning
2
Nitoproof 130 normally 0.5 to 2.0 m per litre depending on
film build required.
At 1 m2 per litre, Nitoproof 120 and 130 will give a dry film
thickness of 0.65 mm.
Precautions
Health and safety
Technical support
Fire
Nitoproof 120, 130 and Fosroc Solvent 103 are flammable.
No smoking during use. In the event of fire extinguish with
CO2 or foam.
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/NP120130/05/A