Documentos de Académico
Documentos de Profesional
Documentos de Cultura
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
NEW
CD Mechanism Type
CDM62-K1BD46A
BU-K1BD46A
KSM-213BFN
SPECIFICATIONS
General
Laser output
Max 44.6 W*
* This output is the value measured at
a distance of 200 mm from the
objective lens surface on the Optical
Pick-up block with 7 mm aperture.
Frequency response
Signal-to-noise ratio
Dynamic range
20 Hz to 20 kHz 0.5 dB
More than 108 dB
More than 87 dB
Harmonic distortion
Power requirements
Where purchased
Power requirements
US, Canada
120 V AC, 60 Hz
Europe
Power consumption
16 W
1 W (at the Power Saving Mode)
Dimensions (approx.)
(w/h/d)
Mass (approx.)
Output
Supplied accessories
Jack
type
Maximum
output
level
Load
impedance
Phono
jacks
2V
Over 10 kilohms
(at 50 kilohms)
LINE OUT
DIGITAL OUT
(OPTICAL)
Optical
18 dBm
output
connector
only)
Remote commander (remote) (1)
Size AA (LR6) batteries (2)
Design and specifications are subject to change without notice.
Sony Corporation
2002D1600-1
2002.04
CDP-CX455
CAUTION
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, metallized knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth Ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microampers).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The limit indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples of
a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
To Exposed Metal
Parts on Set
0.15F
1.5k
Earth Ground
AC
voltmeter
(0.75V)
PART NO.
PARTS No.
4-238-082-0s
4-238-082-1s
4-238-082-2s
MODEL
US
CND
AEP, UK
Abbreviation
CND : Canadian model
SECTION 1
SERVICE NOTE
TABLE OF CONTENTS
1. SERVICE NOTE 3
2. GENERAL 6
3. DISASSEMBLY 7
3-1. Case 8
3-2. MAIN Board 8
3-3. TRANS Board 9
3-4. Front Panel Assembly 9
3-5. JOG Board, DISP Board, KEYBOARD Board 10
3-6. Cover (PT), Table (400) Assembly 11
3-7. LED Board, Guide (Door) 11
3-8. DOOR SW Board 12
3-9. Base (Door Driving) Assembly 13
3-10. Pop-up Assembly 13
3-11. D.MOTOR Board, Motor Assembly (Door) (M603) 14
3-12. T.SENS Board, Holder (Table Sensor 400) 14
3-13. D.SENS (OUT) Board, D.SENS (IN) Board 15
3-14. Back Panel Section 15
3-15. CD Mechanism, Magnet Assembly 16
3-16. LOADING SW Board, LOCK SW Board 17
3-17. CDM Assembly 18
3-18. Motor Assembly (Table) (M601),
Motor Assembly (Loading) (M602) 18
3-19. BU Holder 19
3-20. BD Board, Optical Pick-up (KSM-213BFN) 19
CDP-CX455
4. TEST MODE 20
5. ADJUSTMENTS 25
6. DIAGRAMS 29
6-1. Circuit Boards Location 29
6-2. Block Diagrams 30
6-3. Printed Wiring Board BD Board 32
6-4. Schematic Diagram BD Board 33
6-5. Printed Wiring Board MAIN Board 34
6-6. Schematic Diagram MAIN Board (1/2) 35
6-7. Schematic Diagram MAIN Board (2/2) 36
6-8. Printed Wiring Board Sensor Section 37
6-9. Schematic Diagram Sensor Section 37
6-10. Printed Wiring Board Display Section 38
6-11. Schematic Diagram Display Section 39
6-12. Printed Wiring Board JOG Board 40
6-13. Schematic Diagram JOG Board 41
6-14. Printed Wiring Board Power Section 42
6-15. Schematic Diagram Power Section 43
6-16. IC Block Diagrams 44
6-17. IC Pin Function Descriptions 46
7. EXPLODED VIEWS 50
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
7-9.
Case Section 50
Chassis Section 1 51
Chassis Section 2 52
Front Panel Section 53
Mechanism Section 1 (CDM62-K1BD46A) 54
Mechanism Section 2 (CDM62-K1BD46A) 55
Mechanism Section 3 (CDM62-K1BD46A) 56
Mechanism Section 4 (CDM62-K1BD46A) 57
Optical Pick-up Section (BU-K1BD46A) 58
CDP-CX455
Displayed Contents
TRACK
No.
Displayed Contents
1kHz/0dB/L&R
22
1kHz/-90dB/L&R
20Hz/0dB/L&R
23
40Hz/0dB/L&R
24
100Hz/0dB/L&R
25
400Hz+7kHz(4:1)/0dB/L&R
200Hz/0dB/L&R
26
400Hz+7kHz(4:1)/-10dB/L&R
500Hz/0dB/L&R
27
19kHz+20kHz(1:1)/0dB/L&R
1kHz/0dB/L&R
28
19kHz+20kHz(1:1)/-10dB/L&R
5kHz/0dB/L&R
29
100Hz/0dB/L*
7kHz/0dB/L&R
30
1kHz/0dB/L*
10
10kHz/0dB/L&R
31
10kHz/0dB/L*
11
16kHz/0dB/L&R
32
20kHz/0dB/L*
12
18kHz/0dB/L&R
33
100Hz/0dB/R*
13
20kHz/0dB/L&R
34
1kHz/0dB/R*
14
1kHz/0dB/L&R
35
10kHz/0dB/R*
15
1kHz/-1dB/L&R
36
20kHz/0dB/R*
16
1kHz/-3dB/L&R
37
17
1kHz/-6dB/L&R
38
18
1kHz/-10dB/L&R
39
1kHz w/emphasis/-0.37dB/L&R
19
1kHz/-20dB/L&R
40
5kHz w/emphasis/-4.53dB/L&R
20
1kHz/-60dB/L&R
41
16kHz w/emphasis/-9.04dB/L&R
21
1kHz/-80dB/L&R
NOTE : The contents of Track No. 1 to 41 are the same as those of the current TEST DISC-their titles are displayed.
CDP-CX455
Recorded contents
Display
42
! # $ %&
43
( )
*+ , . /
(28h to 2Fh)
44
012345 67
(30h to 37h)
45
89 : ; <=>?
(38h to 3Fh)
46
@A B C D E F G
(40h to 47h)
47
H I J K L MNO
(48h to 4Fh)
48
P Q R S T U V W (50h to 57h)
49
XYZ [ ] ^ _
(58h to 5Fh)
X Y Z [ \ ] ^ _ (58
50
ab c de f g
(60h to 67h)
51
h i j k l mn o
(68h to 6Fh)
52
pq r s t u vw
(70h to 77h)
53
x y z { I } ~
(78h to 7Fh)
54
i
C PR
(A8h to AFh)
(B0h to B7h)
1
4
1
2
(B8h to BFh)
(C0h to C7h)
59
(C8h to CFh)
60
(D0h to D7h)
61
D
Y
(D8h to DFh)
62
(E0h to E7h)
63
(E8h to EFh)
64
(F0h to F7h)
65
(F8h to FFh)
66
No.66
67
No.67
55
57
58
56
to
99
to
No.99
3
4
1
4
1
2
3
4
to
N All the same
CDP-CX455
SECTION 2
GENERAL
Front Panel
45 6 7 8
q;qaqs qd qf qg
qh
3
qj qk ql w;
2
1
r;
wa ws wd wf
wg
el
ekejehegef
ed es eae; wl
wk wjwh
wa
ws
wd
wf
wg
wh
wj
wk
wl
e;
ea
es
ed
ef
eg
eh
ej
ek
el
r;
FADER button
X-FADE button
NO DELAY button
MEGA CONTROL button and indicator
l AMS L /PUSH ENTER knob and button
p (stop) button
(play) button and indicator
P (pause) button and indicator
ARTIST MODE button and indicator
TOP ARTIST 4 button and indicator
TOP ARTIST 3 button and indicator
TOP ARTIST 2 button and indicator
TOP ARTIST 1 button and indicator
TIME button
TOP ARTIST 8 button and indicator
TOP ARTIST 7 button and indicator
TOP ARTIST 6 button and indicator
TOP ARTIST 5 button and indicator
KEYBOARD jack
TIMER OFF/PLAY switch
CDP-CX455
SECTION 3
DISASSEMBLY
SET
CASE
MAIN BOARD
TRANS BOARD
JOG BOARD,
DISP BOARD,
KEYBOARD BOARD
COVER (PT),
TABLE (400) ASSEMBLY
CD MECHANISM,
MAGNET ASSEMBLY
LED BOARD,
GUIDE (DOOR)
DOOR SW BOARD
CDM ASSEMBLY
LOADING SW BOARD,
LOCK SW BOARD
T. SENS BOARD,
HOLDER
(TABLE SENSOR 400)
POP-UP ASSEMBLY
D. MOTOR BOARD,
MOTOR ASSEMBLY (DOOR)
(M603)
MOTOR ASSEMBLY
(TABLE) (M601),
MOTOR ASSEMBLY
(LOADING) (M602)
BU HOLDER
BD BOARD,
OPTICAL PICK-UP (KSM-213BFN)
CDP-CX455
3-1. Case
1 three screws
(case 3 screw)
2 two screws
(case 3 screw)
3 two screws
(case 3 screw)
5 case
4 two screws
(case 3 screw)
0 MAIN board
2 connector (CN901)
qs two screws (BVTP 3 8)
4 two connectors
(CN505, CN506)
qg bracket (R)
7 three screws
(BVTP 3 8)
qa two screws
(BVTP 3 8)
1 three connectors
(CN503, CN801, CN903)
3 connector (CNP902)
qf bracket (L)
qd
6 connector (CNP504)
CDP-CX455
5 screw (BVTP 3 8)
7 two screws
(PTTWH 3 6)
A
6 bracket (PT)
A
2 connector
(CN602)
3 connector (CN603)
8 TRANS board
4 connector
(CN601)
1 connector
(CN991)
3 connector (CNP503)
CDP-CX455
qd bracket (keyboard)
8 DISP board
qa two screws
(BVTP 2.6 x 8)
9 flat type wire
(17 core)
0 knob
(timer)
3 four screws
(BVTP 2.6 x 8)
4 bracket (case)
assembly
7 eight screws
(BVTP 2.6 x 8)
qf KEYBOARD
board
qs remove two solderings.
5 eleven screws
(BVTP 2.6 x 8)
6 JOG board
2 knob (disc)
10
1 knob (AMS)
CDP-CX455
6 washer
2 LED board
7 guide (door)
5
4
3
11
CDP-CX455
5 two screws
(BVTP 2.6 8)
6 DOOR SW board
4 gear (B)
slider (pop-up)
gear (cam)
12
CDP-CX455
4 door assembly
1 connector
(CN602)
3 pop-up assembly
1 screw (PTPWH 3 6)
13
CDP-CX455
4 remove two
solderings.
3 D.MOTOR board
2 connector
(CN83)
1 four screws
(PTPWH 3 6)
4 T.SENS board
5 screw
(PTTWH 3 6)
3 two connectors
(CN81,CN82)
6 three claws
7 holder
(table sensor 400)
14
CDP-CX455
6 screw
(PTTWH 3 6)
1 screw
(PTTWH 3 6)
4 screw
(PSW 3 8)
5 D.SENS (OUT) board
4 bracket (CDM)
7 four screws
(BVTP 3 8)
5
15
CDP-CX455
7 CD mechanism
When re-assembling,
align the positions as shown.
4 magnet assembly
8 washer
6 spring
16
CDP-CX455
2 screw
(BVTP3 8)
1 rotate the pulley (400) in the
direction of the arrow Afully.
3 rotate the pulley (400) in the
direction of the arrow Bfully.
A
B
7 gear (center)
8 screw
(BVTP 3 8)
9 LOCK SW
board
LOADING SW board
5 tapping screw
4 belt
6 pulley (400)
claws
0 screw
(BVTP 2.6 8)
Leads
position
qa LOADING SW
board
LOCK SW board
17
CDP-CX455
1 connector (CN603)
6 CDM assembly
2 connector (CN601)
4 four screws
(BVTP 3 8)
3 screw (PSW 3 8)
5 seven screws
(BVTP 3 8)
1 two belts
3 remove two
solderings.
7 L.T. MOTOR
board
5 remove two
solderings.
2 three screws
(PTPWH 2.6 8)
18
CDP-CX455
3-19. BU Holder
3 remove two
solderings.
(spindle)
9 optical pick-up
(KSM-213BFN)
7 two vibration
proof rubbers
4 remove two
solderings.
(sled)
8 two vibration
proof rubbers
6 BD board
2 screw (+B 2 x 5)
19
CDP-CX455
SECTION 4
TEST MODE
Contents
Software version display
BU test mode
CDM test mode
Normal aging mode
Default mode
To exit the mode, usually press the 1/u button to enter the standby state.
(When selecting the Ship mode, the standby mode is automatically entered.)
<3 Buttons Method>
Mode name
DOOR POP UP AGING MODE
ALL LIT MODE
MODEL NAME DISPLAY
SPRAY MODE
SHIPMENT MODE
Mode name
TOP ARTIST 3 + H +
TOP ARTIST 4 + H +
TOP ARTIST 6 + H +
TOP ARTIST 8 + H +
ARTIST MODE + H +
To exit the mode, press the 1/u button to enter the standby state.
(When selecting the Ship mode, the standby mode is automatically entered.)
20
CDP-CX455
AGING MODE
Mode which repeatedly changes and plays back discs automatically in the unit.
It will repeat aging as long as no errors occur.
If an error occurs during aging, it will stop all servos, motors, etc.
instantaneously, display the error number, and stop operations.
The function serves to maintain the state of the unit when errors
occur.
Sequence of Aging Mode
1.
2.
3.
4.
5.
$
Disc change
$
Load in
$
TOC read
$
Access of last track
$
3 second playback
6.
$
Access of first track
7.
$
3 second playback
8.
$
Load out
1.
$
No. 80
2.
$
No. 320
3.
$
No. 240
4.
$
No. 400
5.
$
No. 160
Aging Procedure
1. Turn on the power and press the TIME , MEGA CONTROL
and 1/u buttons.
2. Rotate DISC/ALBUM/CHARACTER dial, select Aging
Mode and press the dial to start the aging mode.
3. When the disc set mode is set, the and P LEDs blink.
4. Rotate the DISC/ALBUM/CHARACTER dial. The slits (No.
80, 160, 240, 320, 400) for setting the discs will come forward.
Insert the discs into these slits. Do not set the discs in other
slits.
5. Press the button.
6. The LED blinks, the aging mode is set, and aging is started.
7. The aging cycle lasts 3 minutes. If errors occur during aging,
the error number will be displayed on the Fluorescent indicator
tube. (Refer to the following table for the details of the errors.)
8. Aging will be repeated as long as no errors occur.
9. After disc load out, the number displayed on the Fluorescent
indicator tube will increase.
10. To end aging, press the 1/u button .
If an error occurs and the 1/u button is useless, disconnect the
power cord from the outlet.
Display in aging cycle
AGED 10
DISC 180
21
CDP-CX455
Error Display
1. Disc sensor error
2nd
SEC
120
SHUFFLE REPEAT 1 GROUP
1
PROGRAM 1 2 3 X-FADE DELETE
MULTI CD TEXT NO DELAY
CD2 CD3
Disc number
with error
Aging counter
Error code
Contents
No disc in the speified slit, or Disc in the
other slits
2. Mechanism error
2nd
Error code 3
Code number
Contents
1X
Error during table operation
2X
With no problem
X : negligible number
Error code 4
Code number
0X
1X
Contents
With no problem
Error during table operation
X : negligible number
12
Contents
Error during loading in
Error during loading out
With no problem
With no problem
X : negligible number
Y alternating
1234
Code number
Error code 2
Code number
1X
2X
3X
4X
34
56
SEC
78
1
SHUFFLE REPEAT 1 GROUP
PROGRAM 1 2 3 X-FADE DELETE
MULTI CD TEXT NO DELAY
CD2 CD3
3. BD error
2nd
Error code1
Error code3
Error code4
Error code2
alternating
12
34
SEC
56
The state
during aging
Error code
Y alternating
1234
Aging counter
1234
Error code 1
Code number
0X
1X
2X
3X
4X
FX
X : negligible number
Aging counter
Contents
With no problem
With no problem
Error during door initialization
Error during loading initialization
Error during door initialization
With no problem
Code number
01
02
03
04
05
06
22
Contents
From chucking to TOC read
From chucking to TOC read
From TOC read to end of last track playback
From TOC read to end of last track playback
From end of last track playback to end of first
track playback
From end of last track playback to end of first
track playback
CDP-CX455
SHIPMENT MODE
This mode is used for setting the unit to the shipment state.
Do not execute it without a proper reason as it erases the
memory of the title memo recorded by the customer.
Procedure1:
With the power ON, while pressing the TIME button and MEGA
CONTROL button, press the 1/u button.
Rotate the DISC/ALBUM/CHARACTER dial, select Ship Mode
and press the dial. -OFF- is displayed and the standby mode is
automaticaly entered.
Procedure2:
With the power ON, while pressing the ARTIST MODE button
and H button, press the +100 button. -OFF- is displayed and
the standby mode is automatically entered.
DOOR POP UP AGING MODE
This mode is used for performing aging of the CD pop up part
and door open/close.
It is used for checking if operations are performed normally.
Procedure1:
1. With the power ON, while pressing the TIME button and
MEGA CONTROL button, press the 1/u button.
2. Rotate the DISC/ALBUM/CHARACTER dial, select CDM
Testand press the dial.
3. Rotate the DISC/ALBUM/CHARACTER dial, select
DoorPopup Aging and press the dial.
4. Aging starts, and door open/close and up/down operations of
the pop up part are performed continuously.
5. To end this mode, press the 1/u button.
Procedure2:
1. With the power ON, while pressing the TOP ARTIST 3 button
and button, press the +100 button.
2. Aging starts, and door open/close and up/down operations of
the pop up part are performed continuously.
3. To end the mode, press the 1/u button.
23
CDP-CX455
ADJ Mode
1.
To set this mode, connect the test point (AFADJ) on the MAIN
board to Ground, and connect the power supply plug to the outlet.
2.
3.
Turn ON the power of the unit, set disc to disc table, and perform
chucking.
Disconnect the power supply plug from the outlet.
To set ADJ mode, connect the test point (ADJ) of the MAIN
board to Ground, and connect the power supply plug to the
outlet.
In this mode, table rotation and loading operations are not performed
because it is taken that the disc has already been chucked.
Note: The same operations are also performed in the following when
the test point (ADJ) is connected to Ground after turning on
the power.
Direct search (movement of sledding motor) is not performed during accessing
Ignored even when GFS becomes L
Ignored even when the Q data cannot be read
Focus gain does not decrease
To end the ADJ mode
1. Press the 1/u button and disconnect the plug.
2. Remove the wire between ADJ and GND.
Note: When this mode is executed, all title memos recorded will be
erased.
When this button is pressed, line # No. # will be displayed.
However, these will not be displayed for the following special
buttons. However, these will not be displayed for the following
special buttons.
p (stop) button: FL segment check
(Refer to FL Tube Check Patterns)
P (pause) button: FL grid check
(Refer to FL Tube Check Patterns)
The P LED also lights up simultaneously.
(play) button: All FL segment and grid will light up.
LED also lights up simultaneously.
TIMER switch:
When the switch position is PLAY , the
STANDBY LED lights up. It goes OFF
when set to OFF .
Each time this button is pressed, the value of the Got ## keys
increases. Buttons pressed once will not be counted when pressed
again.
FL Tube Check Patterns
Magnified
Segment check
Grid check
When the jog dial and AMS is rotated to the right, the TOP ARTIST LEDs light up in the order of 1n 2..8n ARTIST
MODEnHISTORY ALBUM SELECTnMEGA CONTROL
n1.
When the jog dial and AMS is rotated to the left, the TOP ARTIST LEDs light up in the order of 8n7..1 nMEGA CONTROL
ALBUM SELECTnHISTORYnARTIST MODEn8.
Abbreviation
FL: Fluorescent Indicator Tube
To end the ADJ mode
1. Disconnect the plug.
2. Remove the wire between AFADJ and GND.
Adjustment Location: MAIN board (See page 28)
24
CDP-CX455
SECTION 5
ADJUSTMENTS
Mechanical Adjustments
Pop Up Mechanism Adjustment
1. Turn on the power and set the disc to number 24.
2. With the power ON, while pres sing the TIME and MEGA
CONTROL buttons, press the 1/u button to enter the test mode.
3. Rotate the JOG dial and select CDM Test.
Press the JOG dial.
4. Rotate the JOG dial and select the mechanism adjustment mode.
(Mech Adjust is displayed.)
Press the JOG dial.
5. Keep pressing the TOP ARTIST 1 button to operate the loading
mechanism, and continue pressing until the disc table locks.
(Fig. 1)
6. Keep pressing the TOP ARTIST 2 button to raise the pop up
part.
7. Loosen the adjusting screw, move the screwdriver left and right
until the lever (POP UP) does not touch the slit wall, and secure
the screw. (Fig. 2)
MEGA CONTROL
At this position,this
part will be locked.
Fig. 1
At this position,this
part will be locked.
Fig. 3
Cover (chassis 400)
Swing
Fig. 2
Fig. 4
25
CDP-CX455
RF Level Check
Electrical Adjustment
Note:
1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10M impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.
S-Curve Check
oscilloscope
oscilloscope
BD board
TP (RFAC)
TP (DVC)
Procedure :
1. Connect oscilloscope to test point TP (RFAC) on BD board.
2. Turn Power switch on.
3. Put disc (YEDS-18) in to play the number five track.
4. Confirm that oscilloscope waveform is clear and check RF
signal level is correct or not.
BD board
TP (FE1)
TP (DVC)
RF signal waveform
Procedure :
1. Chuck the disc (YEDS-18) beforehand.
2. Connect oscilloscope to test point TP (FE1) on BD board.
3. With the power ON, while pressing the TIME and MEGA
CONTROL buttons, press the 1/u button.
Rotate the DISC/ALBUM/CHARACTER dial, select BU
Test and press the dial.
4. Rotate the DISC/ALBUM/CHARACTER dial, and select bdt
S CURVE. Press the dial LD AL is displayed.
5. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within 31
Vp-p.
S-curve waveform
symmetry
VOLT/DIV : 1V
TIME/DIV : 400 s
A
Within 3 1 Vp-p
B
6.
26
VOLT/DIV : 500mV
TIME/DIV : 1 s
level : 1.2
+0.25
0.20
Vp-p
CDP-CX455
5.
oscilloscope
MAIN board
TP1
D.SENS OUT D.SENS OUT: Pin 1
GND: Pin 2
GND
H-H OUT: Pin 3
H-H OUT
6.
CH1 CH2
Waveform:
CH1
CH1
D.SENS
D.SENS
1.
2.
3.
4.
H-H
SEC
P = 3 .6 V b = 1 .4 V
SHUFFLE REPEAT 1 GROUP
1
PROGRAM 1 2 3 X-FADE DELETE
MULTI CD TEXT NO DELAY
CD2 CD3
Minimum value
of the peak at the
High/High part of
TSENS1/TSENS2
4.
Maximum value
of the bottom at the
LOW/LOW part of
TSENS1/TSENS2
S tight, screw
(PTTWH 3 6)
CH1
D.SENS
CH2
H-H
Should be at the center
27
CDP-CX455
Adjustment Location :
[ BD BOARD ] Conductor Side
IC 101
TP(RF AC)
TP(DVC)
IC 103
TP(FE1)
Conductor Side
RV501
DISC SENSOR
ADJUSTMENT
GND
TP(AFADJ)
TP(ADJ)
IC504
IC501
TP1
3
28
CDP-CX455
SECTION 6
DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
Waveforms
1 IC104 yd XO
LED board
: internal component.
C : panel designation.
Note:
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part
number specified.
Note:
Les composants identifis par
une marque ! sont critiques
pour la scurit.
Ne les remplacer que par une
pice por tant le numro
spcifi.
A : B+ Line.
B : B Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : STOP
Voltages are taken with a VOM (Input impedance 10 M).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
J : CD
c : digital out
Abbreviation
CND : Canadian model
MAIN board
3.8Vp-p
59ns
1V/DIV, 20ns/DIV
2 IC103 qg (RFAC)
DISP board
TRANS board
(PLAY)
1.3Vp-p
500mV/DIV, 1s/DIV
3 IC101 ra TE
D. SENS
(OUT) board
1.65V
200mV/DIV, 20ms/DIV
KEYBOARD board
4 IC101 el FE
1.65V
T. SENS board
D. MOTOR board
200mV/DIV, 4ms/DIV
5 IC101 wg MDP
DOOR SW board
JOG board
: Through hole.
BD board
7.5 s
2.1 Vp-p
1V/DIV, 4s/DIV
6 IC501 ek X2
LOADING SW board
3.5 Vp-p
62.5 ns
1V/DIV, 20ns/DIV
Indication of transistor
C
Q
L. T. MOTOR board
B E
BC E
LOCK SW board
These are omitted
29
29
CDP-CX455
6-2. Block Diagrams
BD Section
OPTICAL PICK-UP
BLOCK
(KSM-213BFN)
VC
A
IC101
DIGITAL SERVO
DIGITAL SIGNAL PROC.
IC103
RF AMP
27 VC
RF AC 15
50 RFAC
IC901
OPTICAL
OUT
D OUT 64
+5V
B
C
6 A
RFDCO 28
7 B
RFDCI 29
E
F
9 D
FE 16
10 E
FEI 17
39 FE
11 F
Q101
PCMD 66
12 SDIO
BCLK 67
13 BCKIA
LRCK 65
14 LRCKIA
41 TE
TE 18
LD
DRIVE
XTAI 71
40 SE
60 CKO
XTAO 72
1 LD
GND
SW 12
PD
2 PD
X201
16.9MHz
F-
LO 23
LOUT
IC401
LPF
IC302
AMP
IC302
AMP
Q324
MUTE
7
ANALOG
OUT
Q322
MUTE
PO4 36
Q321,325,326,
328,329
MUTE CONT
LMUTE
RO 26
R-CH
PO5 37
R-CH
Q323
MUTE
Q327
MUTE CONT
DOWN S612
UP (POP UP)
IC501 (1/2)
SYSTEM CONTROL
63 XO
SCL 6
18 CH1RO
CH1RI 22
33 FFDR
17 CH1FO
CH1FI 23
34 FRDR
RESET 1
12 CH2FO
CH2FI
31 TFDR
MP3REQ 39
11 CH2RO
CH2RI 7
32 TRDR
A MUTE 43
IC105
6
9
10
11
12
13
OPEN S611
CLOSE (DOOR)
SMUTE 29
97 SDA
SDA 5
IC150
MOTOR/COIL DRIVE
FOCUS
COIL
2ND
CD IN
62 XI
VR
F+
J903
IC104
D/A CONV,
MP3 DECODER
8 C
LD
43 RFDC
DIGITAL
OPTICAL
OUT
99 SCL
18 A MUTE
S621
(LOADING)
DOORSW 78
7 MP3RST
Q501,502
T+
TRACKING
COIL
T-
14 CH3FO
(SLED)
CH3FI
LDSW 79
29 SFDR
M
13 CH3RO
CH3RI 5
30 SRDR
DATA 4
CLOK 6
4 DATA
XLAT 5
20 XLT
SQCK 77
17 SQCK
5 CLK
SCLK 8
16 CH4RO
CH4INS 2
S622
(LOCK)
96 MP3REQ
25 MDP
(SPINDLE) M
15 CH4FO
IC961
LDIN 25
6
MOTOR
DRIVE
SCOR 15
95 SCOR
SQSO 76
15 SUBQ
LDOUT 24
SENS 7
6 SENS DOOROUT 27
DOORIN 26
M602
(LOADING)
M603
(DOOR)
M601
(TABLE)
MUTE 20
2
+3.3V
S101
(LIMIT IN)
SSTP 26
+5V
Q552
TBLL 23
IC941
XRST 2
+5V
46 XRST
19 PWM3
Q941,942
MOTOR
SWITCH
Q951,952
MOTOR
SWITCH
11 PWM1
98 RF SW
Signal Path
: CD
+3.3V
+2.5V
: DIGITAL OUT
4
5
TSENS1 87
IC81-84
TSENS2 91
TABLE
SENSOR
IC121
TSENS3 88
+3.3V
REG
TSENS4 92
+2.5V
REG
+5V
Q81,D81
DISC
SENSOR
DSENS 86
RV501
DISC
SENSOR
30
30
MOTOR
DRIVE
Q562
TBLR 22
12 PWM2
CDP-CX455
Main Section
IC501 (2/2)
SYSTEM CONTROL
FL701
FLUORESCENT
INDICATOR TUBE
50 D0
57 D7
IC504
SRAM
FLCLK 2
66
3.
25
11
13
. D0
15 D7
19
IC701
FL DRIVER
FLDATA 1
10
FLT1 44
73
.
63
A0 23
.
A14 21
.
2.
60
.
65
.
F1
63 DA
62 SCK
DIG1 40
61 CS
DIG15 54
60 RESET
A0
WE 27
48 WE
Q701
AD1(36) 4
D701-709,711,
712,715
S714,S721
IC702
LED DRIVER
4 DATA
8 CLK
7 RST
39 X1
F2
SEG35 39
Q551
47 CE
F1
SEG01 5
A14
CE 20
F2
DIG16 55
49
.
64
26
.
1
FL702
FLUORESCENT
INDICATOR TUBE
LEDLAT 3
6 LT
QC
24
13,
QP 11,
12
FL701
38 X2
FL702
IC704
FL DRIVER
KEY
BOARD
89 KBDO
13 SIN
15 CLK
5 RESET
FLRST 8
14 SOUT
FLDATAI 100
Q570
45 KBCO
93 KBCI
+5V
12 CS
FLT2 43
DJOG1 84
DJOG2 81
RE701
S701-706
AMS
FUNCTION
KEY
IC703
FUNCTION
KEY
13 RMIN
TJOG1 83
TJOG2 82
+5V
D911
Q911
-30V REG
RECT
RE702
S721-726
DISC/
CHARACTER
FUNCTION
KEY
F2
Q941
-20V REG
VFL
SEG0 43
SEG8 35
IC910
DVDD (+5V)
+5V
REG
SEG9 34
SEG14 29
D921-924
1
RECT
AU VCC
Q941, 942
Q951, 952
11 AD0
S711-714
REMOTE
3 CONTROL 1
RECEIVER
D913
F1
J821
85 KBDI
F2
VFL
X501
16MHz
Q571
T911
F1
IC920
Q931
REG
+7V
+7V
REG
AU VEE
D931-934
1
RECT
IC921
10 AD1
+5V
+5V
REG
M +B
9 AD2
M -B
S741-745
D801
(INSIDE)
FUNCTION
KEY
Q572
LED
DRIVE
7 AD4
T901
31 LED
KEY0 80
S761-768
S751-755
FUNCTION
KEY
FUNCTION
KEY
IC930
MUTE
+5V
6 AD5
LED
DRIVE
+5V
REG
L991
RECT
LINE
FILTER
IC931
+5V REG, RESET
POWER 90
Q576
D710
D901-904
30 SB_LED
5 VOUT
2 RST
RESET 34
STANDBY
VIN 4
D905,906
RECT
ACIN 94
Q901
RELAY
DRIVE
ICSW 28
BUSIN 16
J901
BUSOUT 14
CONTROL A1 II
Q950
J902
31
31
RY991
AC
IN
CDP-CX455
6-3. Printed Wiring Board BD Board
10
11
IC150
IC101
IC103
IC104
E
IC105
IC121
F
(Page 34))
Semiconductor
Location
Ref. No.
Location
IC101
IC103
IC104
IC105
IC121
IC150
D-8
E-8
D-10
E-1
F-2
C-7
Q101
F-4
32
32
CDP-CX455
6-4. Schematic Diagram BD Board
See page 29 for Waveforms. See page 44, 45 for IC Block Diagrams.
See page 46 for IC Pin Function Description.
IC B/D
IC B/D
33
33
CDP-CX455
6-5. Printed Wiring Board MAIN Board
9
Semiconductor
Location
KEYBOARD
(Page 42)
(Page 42)
(Page 42)
(Page 37)
Ref. No.
(Page 38)
IC930
IC931
IC921
IC910
IC920
(Page 40)
D
DISP
(Page 38)
IC402
E
IC401
IC901
IC302
(Page 40)
(Page 32)
IC501
IC504
(Page 37)
34
34
Location
D327
D329
D501
D502
D503
D551
D941
D942
D-4
D-3
G-4
H-7
H-6
G-8
C-8
C-8
IC302
IC401
IC402
IC501
IC504
IC901
IC910
IC920
IC921
IC930
IC931
F-3
E-4
E-3
G-6
G-7
F-2
B-4
C-3
B-3
B-4
B-5
Q321
Q322
Q323
Q324
Q325
Q326
Q327
Q328
Q329
Q421
Q422
Q423
Q424
Q425
Q426
Q501
Q502
Q551
Q552
Q562
Q570
Q571
Q572
Q576
Q941
Q950
D-5
E-3
E-2
D-2
D-3
E-5
D-4
D-3
D-3
D-5
E-2
E-2
D-2
D-3
D-5
F-5
F-5
G-7
B-6
B-6
B-7
B-7
H-6
H-7
C-8
B-2
CDP-CX455
See page 29 for Waveforms. See page 48 for IC Pin Function Description.
DISP
41
4.7k
4.7k
10k
35
35
39
CDP-CX455
6-7. Schematic Diagram MAIN Board (2/2)
A
A
IC B/D
36
36
CDP-CX455
6-8. Printed Wiring Board Sensor Section
IC84
4.9
4.9
H
B
IC83
(1/2)
CN801
1.1
TO
MAIN BOARD
CN801
(Page 34)
(Page 35)
4.9
IC82
4.9
(Page 35)
IC81
F
1.1
(1/2)
CN504
4.9
1-683-723-
4.9
1.1
CN504
(Page 34)
1-683-730-
1.1
1-683-724-
37
37
DISC SENSOR
CDP-CX455
6-10. Printed Wiring Board Display Section
(Page 40)
10
11
(Page 34)
IC703
B
63
KEYBOARD BOARD
B
TO
MAIN BOARD
CN503
(Page 34)
IC701
E
2
1
3
MODE
4
5
1-683-722-
IC702
11
(11)
KEYBOARD
F
S768
TIMER
Semiconductor
Location
Ref. No.
38
38
Location
D701
D702
D703
D704
D705
D706
D707
D708
D709
D710
E-5
E-4
E-3
E-2
E-2
F-5
F-4
F-3
F-2
E-7
IC701
IC702
IC703
C-3
D-2
A-1
Q701
D-3
CDP-CX455
6-11. Schematic Diagram Display Section
IC B/D
39
39
CDP-CX455
See page 29 for Circuit Boards Location.
A
(Page 38)
DISC EJECT
C
IC704
D
E
(Page 34)
F
(Page 34)
40
40
CDP-CX455
6-13. Schematic Diagram JOG Board
IC B/D
41
41
CDP-CX455
6-14. Printed Wiring Board Power Section
3
CN902
(Page 34)
A
IC941
IC961
1-683-7281-683-729-
B
CN903
(Page 34)
C
CN901
1-683-725-
(Page 34)
1-683-726-
Semiconductor
Location
BOARD
Ref. No.
1-683-727-
1-676-829-
42
42
Location
D901
D902
D903
D904
D905
D906
D907
D911
D912
D913
D921
D922
D923
D924
D931
D932
D933
D934
D935
D991
B-2
B-2
B-2
B-2
B-2
B-2
B-1
E-3
E-4
D-4
D-3
D-3
E-3
E-3
D-3
D-3
D-3
D-4
C-3
C-3
IC941
IC961
B-2
B-3
Q901
Q911
Q931
Q941
Q942
Q951
Q952
C-3
E-4
C-3
A-4
A-4
B-4
A-4
CDP-CX455
6-15. Schematic Diagram Power Section
2.2k
US,CND
+5V
1k
2.2k
GND
VCC
2.2k
AC IN
(2/2)
CN902
(Page 36)
RELAY
F1
F2
V.DISP
0.8
AU.VEE
GND
GND
(2/2)
CN901
AU.VCC
(Page 36)
GND
-30V REG
-32.8
-39.8
M.VCC
T.MOTOR CONT
T.MOTOR CONT
(Page 35)
D.MOTOR CONT
L.MOTOR CONT
D.MOTOR CONT
GND
L.MOTOR CONT
(1/2)
CN903
LOADING SW
DOOR SW
4.7k
-33.4
12.3
-12.3
-12.3
-12.3
-13
-12.4
-12.4
-12.3
-12.3
-12.3
-12.3
IC B/D
1
1
12.3
1.4
1.4
-13
IC B/D
1.4
1.3
1.3
-13
-12.9
-13
1.7
2.2k
2.2k
-12.9
-13
-13
MOTOR SWITCH
43
43
CDP-CX455
PO1
PO0
DOUT
TESTP
VSSR
VRAR
RO
VDAR
VDAL
LO
VRAL
VSSL
VSS
STANDBY
VDD
LRCKIB
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
QD
QE
QF
QG
QH
QI
QJ
QK
QL
QM
QN
QC
24
23
22
21
20
19
18
17
16
15
14
13
0
D
1
D
DAC
DIT
CK
0
R
CK
0
R
CK
0
R
CK
0
R
CK
0
R
CK
0
R
CK
CK
0
R
CK
0
R
CK
0
R
CK
13 BCKIA
Y-Pointer
register
Audio I/F
CK
CK
CK
CK
CK
CK
CK
CK
CK
D
0
CK
RST
CLK
10
Microcom. I/F
DIG15/SEG10
DIG14/SEG11
DIG13/SEG12
DIG12/SEG13
DIG11/SEG14
DIG10/SEG15
DIG9/SEG16
DIG8/SEG17
DIG7
DIG6
DIG5
25 24 23
DIGITAL/SEGMENT
OUTPUT CIRCUIT
SEG7 33
36
33
SEG6 37
SEG5 38
33
33
SEG4 39
33
SEG3 40
33
SEG2 41
33
SEG1 42
SEG0 43
4 /MILP
Instruction
Decoder
PROM
1k *3
=12k word
10bit
PRAM
256 word
33 32 31 30 29 28 27 26
DIG16/SEG9 34
DIG17/SEG8 35
5 SDA
DISPLAY CONTROL
CIRCUIT
11
12
DIGITAL
OUTPUT CIRCUIT
22
21
20
19
18
DIG4
DIG3
DIG2
DIG1
DIG0
MODE
REGISTER
MEMORY
ADDRESS
DISPLAY
RAM
3 /MICS
TRANSFER
COUNTER
17 VEE
16 VEE
1 /RESET
Timing
Generator
NOISE FILTER
55
56
57
58
59
60
61
62
63
64
PI3
PI4/CLCK
VDD
PI5/DATA
TSTIN/SFSY
FI2/SBSY
VSSP
PDO
VCOI
VDDP
CKO
VDDX
XI
XO
VSSX
TRIGGER
A-D
CONVERTER
VDD 44
44
44
SELECTOR/A-D
CONTROL CIRCUIT
CLOCK
GENERATOR
6 7 8 9 10 11
AN5
54
RESET
53
XIN
52
VSS
51
XOUT
50
NOISE FILTER
VDD
49
PI2
SERIAL
I/O
AN4
AN3
AN2
AN1
AN0
VC0
QP
LT
COMMAND
ANALYTIC CIRCUIT
SubQ
I/F
QO
SQP
GND
Program
Control
Y-Bus
X-Bus
1Mbit
SRAM
I-Bus
5
OE
DATA
VCC
2 MIMD
General
Input Port
CK
10 BCKO
YRAM
4k word
SRAM I/F
CK
11 LRCKO
XRAM
4k wors
Interrupt
Control
PI0 46
CK
7 /WIACK
FI1 44
VSS 48
CK
QB
A2
A1
A0
MY
6 SCL
Timer
9 SDO
MX
CROM
4k word
*7
register
XO X1 X2
Y0 Y1 Y2
MZ
ERAM
2k word
AX
ALU
X-Pointer
register
AY
A3
AMUTE 43
DRAM I/F
CK
CK
CK
12 SDIO
MAC
Address Calc.
2sets
Fiag
VDDM 42
C-Pointer
register
General
Output Port
MP3REQ 39
IRQ 41
CK
14 LRCKIA
PO6 38
VSS 40
DAC
Bus
Switch
PO5 37
CK
15 SDI1
VDDT 35
PI1 47
QA
PO3 34
VSSM 45
0
R
16 BCKIB
PO2 33
PO4 36
CK
15
14
13
12
SCLK
SOUT
SIN
CS
CK
CDP-CX455
POFF
GND
GND
TSD
Band Gap
VSENCE2
VCC
CT
GND
+VIN1
VEE
+VIN2
VIN2
VOUT2
VSENCE1
VOUT1
VIN1
1 2 3 4 5 6 7 8 9 10
RW/ROM
30 DC OFST
29 RFDCI
28 RFDCO
C
D
DVC
DVC
VCC
VC
DVC
VC
RW/ROM
VOFST
27 VC
VC
LD
EQ
26 RFC
25 VFC
24 BST
RFAC
VCA
23 RFG
VCC
22 VCC
PD
EQ IN
APC AMP
EQ ON/OFF
RW/ROM
AC SUM
GND
RFAC
SUMMING
AMP
A
A
A
B
C
D
B
C
C D
21 CEI
20 CE
D
DVC
A
B
C
D
6
7
8
9
VOFST
VC
RW/ROM
19 TE BAL
RW/ROM
E 10
GM
F 11
GM
SW 12
APC-OFF
(Hi-Z)
RW/ROM
(H/L)
18 TE
VC
RW/ROM
RW/ROM
DVCC 13
B
DVC
DVC 14
D
A
17 FEI
VOFST
16 FE
C
DVC
VC
RW/ROM
RFAC 15
45
CDP-CX455
Pin Name
I/O
Description
/RESET
MIMD
/MICS
/MILP
SDA
I/O
SCL
/MIACK
VDDT
SDO
10
BCKO
11
LRCKO
12
SDI0
Data input 0
13
BCKIA
14
LRCKIA
LR clock input A
15
SDI1
16
BCKIB
17
LRCKIB
18
VDD
19
STANDBY
20
VSS
21
VSSL
22
VRAL
23
LO
24
VDAL
25
VDAR
26
RO
27
VRAR
28
VSSR
29
TESTP
30
DOUT
31 to 34
PO0 to PO3
35
VDDT
36
PO4
37
PO5
38
PO6
39
MP3REQ
40
VSS
41
IRQ
42
VDDM
43
AMUTE
44
FI1
45
VSSM
46, 47
PI0, PI1
48
VSS
49, 50
PI2, PI3
51
PI4/CLCK
52
VDD
53
PI5/DATA
54
TSTIN/SFSY
55
FI2/SBSY
46
CDP-CX455
Pin No.
Pin Name
I/O
56
VSSP
Description
57
PDO
58
VCOI
59
VDDP
60
CKO
61
VDDX
62
XI
63
XO
64
VSSX
47
CDP-CX455
Pin Name
I/O
FLDATA
Data signal output to the fluorescent indicator drivers amd LED driver
Description
FLCLK
Clock signal output to the fluorescent indicator drivers and LED driver
LEDLAT
DATA
CLK
SENS
MP3RST
FLRST
Reset signal output to the the fluorescent indicator driver amd LED driver
EVDD
10
EVSS
11
PWM1
12
PWM2
13
RMIN
14
BUSOUT
15
SUBQ
16
BUSIN
17
SQCK
18
AMUTE
19
PWM3
20
XLT
21
IC/VPP
Connected to ground
22
TBLR
23
TBLL
24
LDOUT
25
LODIN
26
DOORIN
27
DOOROUT
28
ICSW
29
SMUTE
30
SBLED
31
LED
32
DSENSOUT
33
H-HOUT
34
RESET
35
XT1
36
XT2
37
REGC
38
X2
39
X1
40
VSS
Ground
41
VDD
Power supply
42
CLKOUT
43
FLT2
44
FLT1
45
KBCO
46
XRST
47
CE
48
WE
49
A4
50
D0
I/O
48
CDP-CX455
Pin No.
Pin Name
I/O
51 to 57
D1 to D7
I/O
Description
58
BVDD
59
BVSS
60, 61
A13, A14
62
A0
63 to 70
A5 to A12
71 to 73
A1 to A3
74
AVDD
75
AVSS
76
AVREF
77
ADJ
selector (ADJ/AFADJ)
78
DOORSW
79
LDSW
80
KEY0
81
DJOG2
82
TJOG2
83
TJOG1
84
DJOG1
85
KBDI
86
DSENS
87
TSENS1
88
TSENS3
89
KBDO
90
POWER
91
TSENS2
92
TSENS4
93
KBCI
94
ACIN
95
SCOR
96
MP3REQ
97
SDA/SI0
I/O
98
RFSW/SO0
99
SCL/SCK0
100
FLDATA_I
49
CDP-CX455
SECTION 7
EXPLODED VIEWS
NOTE:
-XX, -X mean standardized parts, so they may
have some difference from the original one.
Items marked * are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
4
1
#1
#1
7
5
#1
#1
#1
#1
#1
not supplied
#1
not supplied
#1
#1
3
A
CHASSIS SECTION 1
#1
Ref. No.
1
2
2
3
4
50
Part No.
Description
4-985-553-11
A-4727-715-A
A-4727-805-A
3-383-699-01
4-210-291-01
CUSHION
MAIN BOARD, COMPLETE (AEP, UK)
MAIN BOARD, COMPLETE (US, CND)
CLAMP (EDGE)
SCREW (CASE 3 TP2)
Remarks
Ref. No.
5
6
7
#1
Part No.
Description
4-226-855-11
4-226-841-01
1-824-181-11
7-685-646-79
CASE
COVER (PT)
WIRE (FLAT TYPE) (31 CORE)
SCREW +BVTP 3X8 TYPE2 N-S
Remarks
CDP-CX455
#1
53
51
#2
52
54
61
#1
63
#1
not supplied
#1
T911
55
62
T901
#1
#1
#1
not supplied
56
not supplied
not supplied
#1
CNP901
58
59
57
MECHANISM SECTION 1
(CDM62-K1BD46A)
CHASSIS SECTION 2
#4
#1
Ref. No.
Part No.
Description
51
52
53
54
55
4-215-968-01
4-226-833-01
1-683-730-11
X-4952-500-1
3-701-447-21
56
57
58
* 59
61
4-226-834-01
3-356-601-11
X-4952-641-1
3-703-244-00
3-703-249-01
62
62
Ref. No.
Part No.
Description
63
0 CNP901
0 CNP901
0 T901
0 T901
4-226-876-01
1-575-651-91
1-783-531-41
1-437-709-11
1-437-718-11
COVER (CDM)
CORD, POWER (AEP, UK)
CORD, POWER (US, CND)
TRANSFORMER, POWER (US, CND)
TRANSFORMER, POWER (AEP, UK)
COVER (TABLE)
SCREW, STEP
DOOR ASSY
BUSHING (2104), CORD
SCREW, S TIGHT, +PTTWH 3X6
0 T911
0 T911
#1
#2
#4
1-435-327-11
1-435-328-11
7-685-646-79
7-685-650-79
7-685-903-11
Remarks
Remarks
51
CDP-CX455
#4
#1
101
not supplied
101
103
#1
104
#1
not supplied
#7
114
105
106
#7
102
#5
not supplied
#5
#5
107
101
110
108
111
MECHANISM SECTION 2
(CDM62-K1BD46A)
109
109
not supplied
#1
113
#1
#1
Ref. No.
Ref. No.
#7
Part No.
Description
Part No.
Description
101
102
103
104
105
3-703-249-01
1-683-724-11
1-676-828-11
4-225-873-01
1-683-723-11
110
111
112
113
114
4-216-093-01
4-216-092-02
4-965-822-01
4-931-169-01
4-216-088-02
ROLLER
HOLDER (ROLLER)
FOOT
FOOT
GUIDE (DISC)
106
107
108
* 109
4-216-096-01
3-701-447-21
4-216-089-01
3-378-400-01
#1
#4
#5
#7
7-685-646-79
7-685-903-11
7-685-645-79
7-682-948-01
52
Remark
112
Remark
CDP-CX455
162
161
165
FL701
162
159
160
162
not
supplied
158
162
164
163
not
supplied
166
not
supplied
162
162
FL702
158
157
162
154
162
not
supplied
152
153
156
151
155
Ref. No.
Part No.
Description
151
151
152
153
154
155
X-4954-416-2
X-4954-471-3
4-219-323-01
4-977-358-01
4-996-698-61
4-226-847-01
156
157
158
159
160
4-226-846-01
X-4952-642-2
4-985-553-21
3-917-216-21
1-824-257-11
KNOB (DISC)
BRACKET (CASE) ASSY
CUSHION
KNOB (TIMER)
WIRE (FLAT TYPE) (17 CORE)
Remark
Ref. No.
Part No.
Description
161
161
162
163
164
A-4727-719-A
A-4727-720-A
4-951-620-01
1-683-722-11
A-4727-722-A
164
165
166
FL701
FL702
A-4727-721-A
4-982-811-21
4-929-709-31
1-518-802-11
1-518-803-11
Remark
53
CDP-CX455
208
212
#6
207
213
209
211
204
204
213
207
214
215
#6
206
210
204
204
203
202
220
216
204
218
205
217
M603
202
219
#1
201
Ref. No.
Part No.
Description
Part No.
Description
201
202
203
204
205
4-226-827-02
4-216-093-01
4-216-100-01
4-933-134-11
4-226-832-01
213
214
215
216
217
3-701-441-21
4-226-828-02
4-226-829-01
4-226-831-01
4-226-830-01
WASHER
GEAR (CAM)
GEAR (PULLEY)
GEAR (B)
GEAR (A)
206
207
208
209
210
4-216-099-01
4-216-103-01
4-998-716-01
4-216-102-01
4-228-352-01
SLIDER (POP-UP)
SPRING (POP-UP), COMPRESSION
SCREW, BU FITTING
SHAFT (POP-UP FULCRUM)
LEVER (POP-UP 400)
218
219
220
M603
#1
1-683-728-11
1-683-729-11
4-951-620-01
1-763-790-11
7-685-646-79
DOOR SW BOARD
D.MOTOR BOARD
SCREW (2.6X8), +BVTP
MOTOR, DC (DOOR)
SCREW +BVTP 3X8 TYPE2 N-S
211
212
#6
54
Remark
Ref. No.
Remark
CDP-CX455
254
not supplied
255
not supplied
256
252
251
253
257
259
258
259
MECHANISM SECTION 3
(CDM62-K1BD46A)
Ref. No.
251
252
253
254
255
Part No.
Description
4-216-081-01
3-701-441-21
3-701-446-21
4-216-082-01
A-4672-768-A
Remark
Ref. No.
256
257
258
259
260
Part No.
Description
X-4950-901-5
4-216-086-01
4-216-085-01
4-957-577-01
4-992-054-01
HOLDER ASSY, BU
SPRING (F-2), TENSION
SPRING (F-1), TENSION
SCREW PTP WH (2.6X8) (DIA. 10)
RUBBER, VIBRATION PROOF
Remark
55
CDP-CX455
302
304
303
#6
305
#1
307
308
309
311
312
306
313
310
314
301
303
302
#6
307
MECHANISM SECTION 4
(CDM62-K1BD46A)
Ref. No.
Part No.
Description
301
302
303
304
305
X-4952-499-1
4-216-067-01
3-701-441-21
X-4952-501-1
X-4952-502-1
306
307
308
56
Remark
Ref. No.
Part No.
Description
309
310
311
312
313
4-216-077-01
4-225-871-01
X-4950-900-1
4-216-080-01
4-216-079-02
314
#1
#6
Remark
CDP-CX455
#7
356
351
359
357
360
#3
#1
352
361
357
353
362
#3
353
358
358
not supplied
360
363
M602
M601
354
355
Ref. No.
Part No.
Description
351
352
353
354
355
4-225-865-01
1-683-725-11
X-4952-503-1
1-683-727-11
4-933-134-11
SLIDER (400)
LOCK SW BOARD
LEVER (FULCRUM 400) ASSY
L.T.MOTOR BOARD
SCREW (+PTPWH M2.6X8)
356
357
358
359
A-4672-676-B
4-225-876-01
4-225-870-01
4-216-057-01
CAM ASSY
BELT (400)
PULLEY (400)
GEAR (CENTER 2)
Remark
Ref. No.
Part No.
Description
360
361
362
363
M601
4-216-058-01
4-951-620-01
1-683-726-11
4-225-869-01
A-4672-895-A
GEAR (CENTER)
SCREW (2.6X8), +BVTP
LOADING SW BOARD
GEAR (TABLE 400)
MOTOR (400) ASSY (TABLE)
M602
#1
#3
#7
A-4672-895-A
7-685-646-79
7-685-648-79
7-682-948-01
Remark
57
CDP-CX455
403
402
Ref. No.
Part No.
401
402
0 403
58
Description
401
Remark
CDP-CX455
SECTION 8
ELECTRICAL PARTS LIST
BD
Note:
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifis par une
marque ! sont critiques pour la
scurit.
Ne les remplacer que par une
pice portant le numro spcifi.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
Description
Remark
1-164-315-11
1-107-826-11
1-164-315-11
1-162-967-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
470PF
0.0033uF
22PF
5.00%
10.00%
5.00%
10%
5%
C108
C109
C110
C111
C113
1-164-360-11
1-164-360-11
1-107-826-11
1-126-607-11
1-128-995-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
0.1uF
47uF
100uF
16V
16V
10.00% 16V
20%
4V
20%
10V
C114
C115
C116
C117
C118
1-162-964-11
1-128-995-21
1-107-826-11
1-164-360-11
1-115-156-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
100uF
0.1uF
0.1uF
1uF
10%
50V
20%
10V
10.00% 16V
16V
10V
C119
C120
C121
C131
C132
1-115-156-11
1-126-607-11
1-117-920-11
1-162-968-11
1-162-968-11
CERAMIC CHIP
ELECT CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
47uF
10uF
0.0047uF
0.0047uF
20%
20.00%
10%
10%
C133
C150
C151
C152
C158
1-117-863-11
1-128-995-21
1-164-360-11
1-164-360-11
1-162-966-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
10.00% 6.3V
100uF
20%
10V
0.1uF
16V
0.1uF
16V
0.0022uF 10%
50V
C201
C202
C203
C205
C206
1-126-246-11
1-164-360-11
1-162-964-11
1-164-360-11
1-126-607-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
220uF
0.1uF
0.001uF
0.1uF
47uF
C207
C208
C209
C211
C212
1-164-360-11
1-164-360-11
1-162-927-11
1-107-826-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
100PF
5%
0.1uF
10.00%
0.0022uF 10%
C213
C215
C216
C222
C223
1-162-967-11
1-117-863-11
1-162-970-11
1-164-360-11
1-126-607-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.0033uF
0.47uF
0.01uF
0.1uF
47uF
20%
10%
20%
50V
16V
50V
50V
50V
10V
4V
6.3V
50V
50V
4V
16V
50V
16V
4V
16V
16V
50V
16V
50V
10%
50V
10.00% 6.3V
10%
25V
16V
20%
4V
Ref. No.
SEMICONDUCTORS
In each case, u: , for example:
uA...: A..., uPA...: PA..., uPB...: PB...,
uPC...: PC..., uPD...: PD...
CAPACITORS
uF : F
COILS
uH : H
Abbreviation
CND : Canadian model
Part No.
Description
Remark
C224
C226
C227
C229
C230
1-164-360-11
1-126-607-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
0.1uF
0.1uF
0.1uF
C231
C232
C250
C251
C252
1-128-995-21
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.1uF
0.1uF
0.1uF
C253
C254
C255
C256
C257
1-164-360-11
1-162-919-11
1-164-360-11
1-164-360-11
1-165-112-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22PF
0.1uF
0.1uF
0.33uF
C258
C259
C260
C261
C263
1-162-975-11
1-164-360-11
1-126-246-11
1-126-607-11
1-117-920-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
TANTAL. CHIP
24PF
0.1uF
220uF
47uF
10uF
5.00% 50V
16V
20%
4V
20%
4V
20.00% 6.3V
C264
C265
C266
C267
C268
1-126-607-11
1-126-607-11
1-164-360-11
1-162-966-11
1-162-966-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
0.1uF
0.0022uF
0.0022uF
20%
20%
C269
C270
C271
C276
C292
1-117-920-11
1-162-960-11
1-162-995-11
1-164-360-11
1-115-156-11
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
220PF
0.022uF
0.1uF
1uF
20.00% 6.3V
10%
50V
50V
16V
10V
C297
20%
20%
5%
10%
10%
0.1uF
16V
4V
16V
16V
16V
10V
16V
16V
16V
16V
16V
50V
16V
16V
16V
4V
4V
16V
50V
50V
16V
1-784-879-21 CONNECTOR,FFC(LIF(NON-ZIF))31P
1-777-937-11 CONNECTOR, FFC/FPC 16P
< FERRITE BEAD/CONDUCTOR >
FB101
FB102
FB103
FB104
FB105
1-500-283-11
1-500-283-11
1-500-283-11
1-500-283-11
1-216-864-11
FERRITE
FERRITE
FERRITE
FERRITE
METAL CHIP
0UH
0UH
0UH
0UH
0
5%
1/16W
59
CDP-CX455
BD
Ref. No.
FB111
FB251
FB291
FB292
D.MOTOR
D.SENS(IN)
Part No.
Description
1-216-864-11
1-414-594-11
1-216-864-11
1-216-864-11
METAL CHIP
FERRITE
METAL CHIP
METAL CHIP
D.SENS(OUT)
Remarks
0
0UH
0
0
5%
1/16W
5%
5%
1/16W
1/16W
Ref. No.
DISP
Part No.
Description
R232
R233
R249
R250
R251
1-216-817-11
1-216-817-11
1-216-817-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
220
220
5%
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
1/16W
R252
R253
R254
R265
R266
1-216-857-11
1-216-821-11
1-216-845-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
1K
100K
220
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R271
10K
5%
1/16W
< IC >
IC101
IC103
IC104
IC105
IC121
8-752-408-73
8-752-089-74
6-701-810-01
6-700-226-01
6-701-808-01
IC
IC
IC
IC
IC
CXD3068Q
CXA2581N-T4
TC94A20F-CX4
TC74LVX04FT(EL)
BA33C25FP-E2
IC150
8-759-677-90 IC BA5947FP-E2
< SWITCH >
< TRANSISTOR >
S101
Q101
8-729-049-31 TRANSISTOR
2SB710A-RTX
< VIBRATOR >
R101
R102
R103
R104
R105
1-216-864-11
1-216-833-11
1-216-845-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
10K
100K
10K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R111
R113
R114
R117
R118
1-216-846-11
1-216-828-11
1-218-745-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
120K
3.9K
160K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R120
R122
R123
R124
R125
1-216-846-11
1-216-845-11
1-216-797-11
1-216-797-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
120K
100K
10
10
12K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R126
R131
R132
R133
R151
1-216-834-11
1-216-845-11
1-216-853-11
1-216-825-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
100K
470K
2.2K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R152
R153
R155
R156
R201
1-216-849-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
0
0
0
33K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R202
R203
R204
R205
R206
1-216-833-11
1-216-845-11
1-216-825-11
1-216-821-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
2.2K
1K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R207
R213
R214
R215
R216
1-216-857-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
0
0
0
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C702
C703
C781
C782
C784
1-164-159-11
1-164-159-11
1-104-665-11
1-104-665-11
1-162-282-31
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
0.1uF
0.1uF
100uF
100uF
100PF
20.00%
20.00%
20.00%
20.00%
10%
50V
50V
10V
10V
50V
R218
R219
R220
R230
R231
1-216-821-11
1-216-821-11
1-216-821-11
1-216-813-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
220
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C785
C786
C787
C788
C789
1-162-282-31
1-162-282-31
1-162-306-11
1-162-215-31
1-164-159-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
0.01uF
47PF
0.1uF
10%
10%
20.00%
5%
20.00%
50V
50V
16V
50V
50V
60
D81
8-719-055-84 DIODE GL528VS1
**************************************************************
A-4727-719-A DISP BOARD, COMPLETE (US, CND)
A-4727-720-A DISP BOARD, COMPLETE (AEP, UK)
*****************************
4-982-811-21 HOLDER (FL)
< CAPACITOR >
CDP-CX455
DISP
Ref. No.
C791
C792
C793
Part No.
Description
1-162-286-31 CERAMIC
1-162-294-31 CERAMIC
1-164-159-11 CERAMIC
Remarks
220PF
0.001uF
0.1uF
Ref. No.
10%
50V
10%
50V
20.00% 50V
DIODE
DIODE
DIODE
DIODE
DIODE
D706
D707
D708
D709
D710
8-719-046-39
8-719-046-39
8-719-046-39
8-719-046-39
8-719-046-44
DIODE
DIODE
DIODE
DIODE
DIODE
Description
Remarks
S741
S742
S743
S744
S745
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
S751
S752
S753
S754
S755
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
S761
S762
S763
S764
S765
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
S766
1-771-349-21 SWITCH, KEYBOARD (?/1)
S768
1-570-157-51 SWITCH, SLIDE (TIMER)
**************************************************************
JOG
D701
D702
D703
D704
D705
Part No.
DOOR SW
< IC >
< RESISTOR >
IC701
IC702
IC703
6-702-066-01 IC PT6302-R-001
8-759-183-47 IC M66310FP
8-759-827-70 IC NJL64H400A-1
R612
R613
R614
1-249-417-11 CARBON
1-249-421-11 CARBON
1-249-421-11 CARBON
1K
2.2K
2.2K
5%
5%
5%
1/4W F
1/4W F
1/4W F
8-729-116-02 TRANSISTOR
BA1A4M-TP
S611
1-786-154-11 SWITCH, ROTARY (DOOR)
S612
1-786-154-11 SWITCH, ROTARY (POP UP)
**************************************************************
1-249-417-11
1-249-421-11
1-249-421-11
1-249-425-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
2.2K
2.2K
4.7K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R753
R754
R755
R762
R763
1-249-421-11
1-249-421-11
1-249-425-11
1-249-417-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
2.2K
4.7K
1K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R764
R765
R766
R767
R781
1-249-421-11
1-249-425-11
1-249-429-11
1-249-433-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
4.7K
10K
22K
100
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
R782
R783
R784
R785
R786
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-843-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
3.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R787
R788
R789
R790
R791
1-249-441-11
1-247-807-31
1-247-807-31
1-249-409-11
1-249-409-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100
100
220
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R792
R793
1-249-409-11 CARBON
1-249-413-11 CARBON
220
470
5%
5%
1/4W F
1/4W F
1-161-494-00
1-161-494-00
1-161-494-00
1-161-494-00
1-161-494-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.022uF
0.022uF
0.022uF
0.022uF
0.022uF
C751
C773
C774
C775
C776
1-161-494-00
1-164-159-11
1-124-584-00
1-162-207-31
1-164-159-11
CERAMIC
CERAMIC
ELECT
CERAMIC
CERAMIC
0.022uF
0.1uF
100uF
22PF
0.1uF
C777
C778
C779
1-162-282-31 CERAMIC
1-164-159-11 CERAMIC
1-164-159-11 CERAMIC
100PF
0.1uF
0.1uF
25V
25V
25V
25V
25V
20.00%
20%
5%
20.00%
25V
50V
10V
50V
50V
10%
50V
20.00% 50V
20.00% 50V
(AEP, UK)
61
CDP-CX455
JOG
Ref. No.
KEYBOARD
Part No.
L.T.MOTOR
Description
LED
Remarks
Ref. No.
Part No.
Description
Remarks
S726
1-771-349-21 SWITCH, KEYBOARD (x)
S767
1-771-349-21 SWITCH, KEYBOARD (G)
**************************************************************
IC704
LOCK SW
8-759-547-59 IC M35500BGP
< CAPACITOR >
< RESISTOR >
R701
R702
R703
R704
R705
1-249-429-11
1-249-417-11
1-249-421-11
1-249-421-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
2.2K
2.2K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R706
R707
R711
R712
R713
1-249-429-11
1-249-433-11
1-249-429-11
1-249-417-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
22K
10K
1K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R714
R721
R722
R723
R724
1-249-421-11
1-249-429-11
1-249-417-11
1-249-421-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
10K
1K
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R725
R726
R727
R731
R741
1-249-425-11
1-249-429-11
1-249-433-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
10K
22K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R751
R771
R772
R773
R774
1-249-429-11
1-247-807-31
1-249-407-11
1-249-407-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100
150
150
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R775
R794
1-247-807-31 CARBON
1-247-807-31 CARBON
100
100
5%
5%
1/4W
1/4W
C821
C822
C823
F
F
F
F
1-164-159-11 CERAMIC
1-164-159-11 CERAMIC
1-126-935-11 ELECT
0.1uF
0.1uF
470uF
20.00% 50V
20.00% 50V
20.00% 10V
F
F
F
F
J821
L821
1-424-122-11 FILTER, NOISE
L822
1-424-122-11 FILTER, NOISE
L823
1-424-122-11 FILTER, NOISE
L824
1-424-122-11 FILTER, NOISE
**************************************************************
1-683-727-11 L.T.MOTOR BOARD
***************
< MOTOR >
S701
S702
S703
S704
S705
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
S706
S711
S712
S713
S714
1-771-349-21
1-771-349-21
1-771-349-21
1-771-349-21
1-692-537-21
S721
S722
S723
S724
S725
62
M601
A-4672-895-A MOTOR (400) ASSY (TABLE)
M602
A-4672-895-A MOTOR (400) ASSY (LOADING)
**************************************************************
1-683-730-11 LED BOARD
**********
4-976-473-01 HOLDER (LED-S)
1-164-159-11 CERAMIC
0.1uF
20.00% 50V
R801
1-249-401-11 CARBON
47
5%
1/4W F
**************************************************************
1-683-725-11 LOCK SW BOARD
**************
< SWITCH >
S622
1-771-604-11 SWITCH, DETECTION (LOCK)
**************************************************************
CDP-CX455
LOADING SW
Ref. No.
Part No.
Description
Remarks
1-249-417-11 CARBON
1-249-421-11 CARBON
1K
2.2K
5%
5%
1/4W F
1/4W F
*
*
Ref. No.
MAIN
Part No.
Description
C542
C543
C550
C551
C591
1-136-287-11
1-131-700-31
1-110-489-11
1-164-159-11
1-104-665-11
MYLAR
FILM
CAPACITOR
CERAMIC
ELECT
0.0047uF
0.47uF
1F
0.1uF
100uF
5.00% 50V
5%
50V
5.5V
20.00% 50V
20.00% 10V
Remarks
C592
C593
C594
C779
1-104-665-11
1-104-665-11
1-104-665-11
1-164-159-11
ELECT
ELECT
ELECT
CERAMIC
100uF
100uF
100uF
0.1uF
20.00%
20.00%
20.00%
20.00%
C913
1-126-767-11 ELECT
1000uF
10V
10V
10V
50V
(AEP, UK)
20.00% 16V
C914
C917
C923
C927
C928
1-126-767-11
1-126-935-11
1-126-767-11
1-126-935-11
1-126-935-11
ELECT
ELECT
ELECT
ELECT
ELECT
1000uF
470uF
1000uF
470uF
470uF
20.00%
20.00%
20.00%
20.00%
20.00%
16V
10V
16V
10V
10V
C933
C934
C935
C936
C938
1-126-933-11
1-126-933-11
1-104-665-11
1-126-962-11
1-126-935-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
100uF
100uF
3.3uF
470uF
20.00%
20.00%
20.00%
20.00%
20.00%
16V
16V
10V
50V
10V
C939
C941
C942
C943
C944
1-164-159-11
1-126-935-11
1-126-935-11
1-126-948-11
1-126-948-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
0.1uF
470uF
470uF
100uF
100uF
20.00%
20.00%
20.00%
20.00%
20.00%
50V
16V
16V
35V
35V
C945
C950
C951
C952
C953
1-104-665-11
1-164-159-11
1-164-159-11
1-164-159-11
1-104-665-11
ELECT
CERAMIC
CERAMIC
CERAMIC
ELECT
100uF
0.1uF
0.1uF
0.1uF
100uF
20.00%
20.00%
20.00%
20.00%
20.00%
10V
50V
50V
50V
10V
C954
1-164-159-11 CERAMIC
0.1uF
20.00% 50V
C301
C302
C303
C304
C305
1-126-965-91
1-130-471-00
1-137-367-11
1-126-965-91
1-126-965-91
ELECT
MYLAR
MYLAR
ELECT
ELECT
22uF
0.001uF
0.0033uF
22uF
22uF
20.00%
5%
5.00%
20.00%
20.00%
C307
C310
C311
C321
C327
1-126-960-11
1-164-159-11
1-164-159-11
1-126-963-11
1-124-282-00
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
1uF
0.1uF
0.1uF
4.7uF
22uF
20.00% 50V
20.00% 50V
20.00% 50V
20.00% 50V
20.00% 25V
C328
C329
C401
C402
C403
1-162-290-31
1-126-963-11
1-126-965-91
1-130-471-00
1-137-367-11
CERAMIC
ELECT
ELECT
MYLAR
MYLAR
470PF
4.7uF
22uF
0.001uF
0.0033uF
10%
20.00%
20.00%
5%
5.00%
50V
50V
50V
50V
50V
C404
C405
C407
C410
C411
1-126-965-91
1-126-965-91
1-126-960-11
1-164-159-11
1-164-159-11
ELECT
ELECT
ELECT
CERAMIC
CERAMIC
22uF
22uF
1uF
0.1uF
0.1uF
20.00%
20.00%
20.00%
20.00%
20.00%
50V
50V
50V
50V
50V
CN501
CN502
CN503
CN505
CN506
C427
C428
C501
C502
C503
1-124-282-00
1-162-290-31
1-164-159-11
1-104-665-11
1-164-159-11
ELECT
CERAMIC
CERAMIC
ELECT
CERAMIC
22uF
470PF
0.1uF
100uF
0.1uF
20.00%
10%
20.00%
20.00%
20.00%
25V
50V
50V
10V
50V
CN801
* CN901
CN903
C504
C505
C508
C509
C510
1-164-159-11
1-164-159-11
1-161-494-00
1-161-494-00
1-161-494-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.022uF
0.022uF
0.022uF
20.00% 50V
20.00% 50V
25V
25V
25V
D327
D329
D501
D502
D503
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
C511
C512
C513
C514
C515
1-161-494-00
1-161-494-00
1-164-159-11
1-164-159-11
1-161-494-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.022uF
0.022uF
0.1uF
0.1uF
0.022uF
25V
25V
20.00% 50V
20.00% 50V
25V
D551
D941
D942
C516
C517
C518
C519
C541
1-164-159-11
1-161-494-00
1-164-159-11
1-126-960-11
1-131-679-31
CERAMIC
CERAMIC
CERAMIC
ELECT
FILM
0.1uF
0.022uF
0.1uF
1uF
0.01uF
20.00% 50V
25V
20.00% 50V
20.00% 50V
5%
50V
IC302
IC401
IC402
IC501
IC504
CONNECTOR,FFC(LIF(NON-ZIF))31P
CONNECTOR, FFC 17P
PIN, CONNECTOR (LIGHT ANGLE)6P
PIN, CONNECTOR (LIGHT ANGLE)9P
PIN, CONNECTOR (LIGHT ANGLE)5P
1SS133T-72
1SS133T-72
1SS133T-72
1SS133T-72
1SS133T-72
< IC >
8-749-015-59
8-749-015-59
8-749-015-59
6-801-221-01
8-759-825-10
IC
IC
IC
IC
IC
BA4558-HT
BA4558-HT
BA4558-HT
uPD703033AYGF-CX4-3BA
LC35256DM-70-TLM
63
CDP-CX455
MAIN
Ref. No.
Part No.
Description
IC901
IC910
IC920
IC921
IC930
8-749-017-31
8-759-039-69
8-759-071-48
8-759-039-69
8-759-173-39
IC
IC
IC
IC
IC
IC931
8-759-658-02 IC BA3993F
Remarks
L501
L921
L950
1-410-396-41 FERRITE
1-410-396-41 FERRITE
1-410-503-11 INDUCTOR
0.45uH
0.45uH
3.3uH
8-729-900-89
8-729-141-26
8-729-141-26
8-729-141-26
8-729-900-65
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144ES
2SC3622ATP-LK
2SC3622ATP-LK
2SC3622ATP-LK
DTA144ES
Q326
Q327
Q328
Q329
8-729-115-52
8-729-029-56
8-729-029-56
8-729-029-56
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BN1L3M-TP
DTA144ES
DTA144ES
DTA144ES
Q421
Q422
Q423
Q424
Q425
8-729-900-89
8-729-141-26
8-729-141-26
8-729-141-26
8-729-900-65
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144ES
2SC3622ATP-LK
2SC3622ATP-LK
2SC3622ATP-LK
DTA144ES
Q426
Q501
Q502
Q551
Q552
8-729-115-52
8-729-900-89
8-729-115-52
8-729-030-09
8-729-900-65
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BN1L3M-TP
DTC144ES
BN1L3M-TP
DTC144VSA-TP
DTA144ES
Q562
Q570
Q571
Q572
Q576
8-729-900-65
8-729-116-02
8-729-116-02
8-729-116-02
8-729-422-57
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA144ES
BA1A4M-TP
BA1A4M-TP
BA1A4M-TP
UN4111
Q941
Q950
8-729-140-97 TRANSISTOR
8-729-620-05 TRANSISTOR
2SB734-T-34
2SC2603TP-EF
1-247-895-00
1-247-843-11
1-247-843-11
1-247-895-00
1-249-422-11
CARBON
CARBON
CARBON
CARBON
CARBON
470K
3.3K
3.3K
470K
2.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R309
R310
R311
R312
R313
1-249-425-11
1-249-429-11
1-249-429-11
1-249-429-11
1-247-895-00
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
10K
10K
10K
470K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R314
1-249-409-11 CARBON
220
5%
1/4W F
64
Ref. No.
Part No.
Description
R315
R317
R321
R322
1-249-409-11
1-249-425-11
1-249-441-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
220
4.7K
100K
2.2K
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
Remarks
R323
R324
R325
R326
R327
1-249-421-11
1-249-421-11
1-249-441-11
1-247-807-31
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
2.2K
100K
100
100K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
R328
R329
R339
R340
R401
1-249-441-11
1-249-441-11
1-247-895-00
1-249-409-11
1-247-895-00
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
470K
220
470K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R402
R403
R406
R407
R409
1-247-843-11
1-247-843-11
1-247-895-00
1-249-422-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
3.3K
470K
2.7K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R410
R411
R412
R413
R414
1-249-429-11
1-249-429-11
1-249-429-11
1-247-895-00
1-249-409-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
470K
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R415
R417
R421
R422
R423
1-249-409-11
1-249-425-11
1-249-441-11
1-249-421-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
220
4.7K
100K
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R424
R425
R426
R439
R440
1-249-421-11
1-249-441-11
1-247-807-31
1-247-895-00
1-249-409-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
100K
100
470K
220
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W F
R501
R502
R503
R504
R505
1-249-441-11
1-249-429-11
1-249-417-11
1-249-421-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
10K
1K
2.2K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R506
R507
R508
R509
R510
1-249-429-11
1-249-441-11
1-249-429-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R511
R512
R513
R514
R515
1-249-429-11
1-249-429-11
1-249-441-11
1-249-429-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100K
10K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R516
R518
R519
R520
R521
1-249-429-11
1-249-429-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R522
R523
R524
R525
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
100
100
100
100
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
F
F
F
F
CDP-CX455
MAIN
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
T.SENS
TRANS
Description
Remarks
R526
1-247-807-31 CARBON
100
5%
1/4W
R527
R528
R529
R530
R531
1-247-807-31
1-247-807-31
1-249-441-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R532
R533
R534
R535
R536
1-249-441-11
1-249-429-11
1-249-425-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
100K
10K
4.7K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R537
R538
R539
R540
R541
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
100
100
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R542
R543
R544
R545
R546
1-247-887-00
1-249-421-11
1-249-441-11
1-249-441-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
220K
2.2K
100K
100K
100
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R550
R551
R552
R553
R554
1-249-429-11
1-249-429-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R570
R571
R591
R931
R932
1-249-425-11
1-249-425-11
1-249-425-11
1-247-887-00
1-249-385-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
4.7K
220K
2.2
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/6W
F
F
F
R941
R942
R943
R944
R950
1-249-389-11
1-249-385-11
1-249-421-11
1-249-421-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7
2.2
2.2K
2.2K
4.7K
5%
5%
5%
5%
5%
1/4W
1/6W
1/4W
1/4W
1/4W
F
F
F
F
F
R951
R952
1-249-429-11 CARBON
1-249-393-11 CARBON
10K
10
5%
5%
1/4W
1/4W F
IC81
IC82
IC83
IC84
8-749-924-18
8-749-924-18
8-749-924-18
8-749-924-18
R81
1-249-416-11 CARBON
820
5%
1/4W F
R82
1-249-416-11 CARBON
820
5%
1/4W F
R83
1-249-416-11 CARBON
820
5%
1/4W F
R84
1-249-416-11 CARBON
820
5%
1/4W F
R85
1-249-415-11 CARBON
680
5%
1/4W F
**************************************************************
A-4727-718-A TRANS BOARD, COMPLETE (AEP, UK)
A-4727-717-A TRANS BOARD, COMPLETE (US, CND)
******************************
1-126-936-11
1-126-960-11
1-128-576-11
1-126-948-11
1-161-494-00
ELECT
ELECT
ELECT
ELECT
CERAMIC
3300uF
1uF
100uF
100uF
0.022uF
20.00%
20.00%
20.00%
20.00%
16V
50V
63V
35V
25V
C921
C922
C930
C931
C932
1-126-768-11
1-126-768-11
1-161-494-00
1-126-768-11
1-126-768-11
ELECT
ELECT
CERAMIC
ELECT
ELECT
2200uF
2200uF
0.022uF
2200uF
2200uF
20.00% 16V
20.00% 16V
25V
20.00% 16V
20.00% 16V
C933
C940
C941
C942
C943
1-126-967-11
1-136-173-00
1-136-173-00
1-109-953-11
1-164-159-11
ELECT
MYLAR
MYLAR
ELECT
CERAMIC
47uF
0.47uF
0.47uF
2.2uF
0.1uF
20.00%
5.00%
5.00%
20.00%
20.00%
50V
50V
50V
50V
50V
C951
C961
C962
C963
C971
1-136-173-00
1-136-165-00
1-164-159-11
1-164-159-11
1-136-165-00
MYLAR
MYLAR
CERAMIC
CERAMIC
MYLAR
0.47uF
0.1uF
0.1uF
0.1uF
0.1uF
5.00%
5.00%
20.00%
20.00%
5.00%
50V
50V
50V
50V
50V
C972
C973
0 C991
0 C992
1-164-159-11
1-164-159-11
1-113-925-11
1-113-924-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.01uF
0.0047uF
0 C993
1-113-924-11 CERAMIC
* TP1
* TP2
20.00% 50V
20.00% 50V
20.00% 250V
20.00% 250V
(US, CND)
0.0047uF 20.00% 250V
(US, CND)
CN601
* CN602
CN603
* CN991
CNP902
1-506-469-11
1-506-469-11
1-568-951-11
1-580-230-11
1-691-767-11
PIN, CONNECTOR 4P
PIN, CONNECTOR 4P
PIN, CONNECTOR 2P
PIN, CONNECTOR (PC BOARD) 2P
PLUG (MICRO CONNECTOR) 5P
65
CDP-CX455
TRANS
Ref. No.
Part No.
Description
Remarks
8-719-210-21
8-719-210-21
8-719-210-21
8-719-210-21
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
11EQS04-TA2B
11EQS04-TA2B
11EQS04-TA2B
11EQS04-TA2B
1SS133T-72
D906
D907
D911
D912
D913
8-719-911-19
8-719-911-19
8-719-024-99
8-719-150-92
8-719-109-93
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-72
1SS133T-72
11ES2-NTA2B
RD33ES-T2B1
MTZJ-T-72-6.2B
D921
D922
D923
D924
D931
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-200-77
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
10E2N-TA2B
D932
D933
D934
D935
D991
8-719-200-77
8-719-200-77
8-719-200-77
8-719-110-41
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
10E2N-TA2B
10E2N-TA2B
10E2N-TA2B
RD15ES-T2B2
1SS133T-72
Ref. No.
Part No.
Description
Remarks
R948
R949
1-249-381-11 CARBON
1-249-381-11 CARBON
1
1
5%
5%
1/4W F
1/4W F
R951
R952
R953
R954
R955
1-247-807-31
1-249-421-11
1-249-441-11
1-249-417-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
2.2K
100K
1K
100K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W
R956
R957
R958
R959
R961
1-247-883-00
1-249-425-11
1-249-381-11
1-249-381-11
1-247-883-00
CARBON
CARBON
CARBON
CARBON
CARBON
150K
4.7K
1
1
150K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W F
1/4W
R962
R963
R964
R965
R966
1-247-860-11
1-247-883-00
1-247-883-00
1-249-431-11
1-249-381-11
CARBON
CARBON
CARBON
CARBON
CARBON
16K
150K
150K
15K
1
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R967
R968
R971
R972
R973
1-249-381-11
1-249-393-11
1-247-883-00
1-247-860-11
1-247-885-00
CARBON
CARBON
CARBON
CARBON
CARBON
1
10
150K
16K
180K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
R974
R975
R976
R977
R978
1-247-885-00
1-249-431-11
1-249-381-11
1-249-381-11
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
180K
15K
1
1
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W F
< IC >
IC941
IC961
8-759-822-38 IC LA6510
8-759-822-38 IC LA6510
< COIL >
0 L991
8-729-620-05
8-729-140-97
8-729-620-05
8-729-029-56
8-729-030-02
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603TP-EF
2SB734-T-34
2SC2603TP-EF
DTA144ESA-TP
UN4213-TA
Q951
Q952
8-729-029-56 TRANSISTOR
8-729-030-02 TRANSISTOR
DTA144ESA-TP
UN4213-TA
1-755-299-11 RELAY
< TRANSFORMER >
0 T901
1-437-709-11 TRANSFORMER, POWER (US, CND)
0 T901
1-437-718-11 TRANSFORMER, POWER (AEP, UK)
0 T911
1-435-327-11 TRANSFORMER, POWER (US, CND)
0 T911
1-435-328-11 TRANSFORMER, POWER (AEP, UK)
**************************************************************
MISCELLANEOUS
**************
1-249-417-11
1-249-429-11
1-249-421-11
1-249-429-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
10K
2.2K
10K
4.7K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W F
7
160
401
0 404
0 CNP901
1-824-181-11
1-824-257-11
1-782-817-11
A-332-881-8A
1-575-651-91
R912
R913
R914
R931
R932
1-249-421-11
1-249-425-11
1-247-807-31
1-249-421-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
4.7K
100
2.2K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
0 CNP901
M601
M602
M603
0 T901
1-783-531-41
A-4672-895-A
A-4672-895-A
1-763-790-11
1-437-709-11
R940
R941
R942
R943
R944
1-247-807-31
1-247-807-31
1-249-421-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
2.2K
100K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W F
R945
R946
R947
1-249-441-11 CARBON
1-247-883-00 CARBON
1-249-425-11 CARBON
100K
150K
4.7K
5%
5%
5%
1/4W
1/4W
1/4W F
66
F
F
F
F
0 T901
1-437-718-11 TRANSFORMER, POWER (AEP, UK)
0 T911
1-435-327-11 TRANSFORMER, POWER (US, CND)
0 T911
1-435-328-11 TRANSFORMER, POWER (AEP, UK)
**************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
CDP-CX455
Ref. No.
Part No.
Description
Remarks
ACCESSORIES
************
1-477-214-11
1-558-626-11
1-770-019-51
1-777-172-11
4-228-696-01
67
CDP-CX455
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
Date
1.0
2002.04
Description of Revision
New