Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Dec 2010
15. Which of the following
communication modes support two
way traffic but in only one direction
at a time?
(A) Simplex
(B) Half-duplex
(C) Three-quarter duplex
(D) Full-duplex
16. Intermediate frequency is used
in
(A) AM transmitter
(B) FM transmitter
(C) Super heterodyne receiver
(D) Frequency division multiplexing
34. Consider the following
communication systems :
1. Telephony
2. Radio communication
3. Microwave communication
4. Optical communication
The correct sequence of these
systems from the point of view of
increasing order of base band
channels each one of them can
accommodate is
(A) 2, 4, 3, 1
(B) 3, 4, 1,
2
(C) 1, 2, 3, 4
(D) 4, 2, 1,
3
43. List I
List II
(a) Frequency Modulation(i)
Envelop detection
(b) Double side suppressed carrier
(ii) Companding
(c) PCM
(iii) Balanced
modulator
(d) Amplitude modulation(iv) Pre
emphasis and de emphasis
Codes :
(a) (b) (c) (d)
(A) (i) (ii) (iii) (iv)
(B) (i) (ii) (iv) (iii)
(C) (iv) (iii) (i) (ii)
(D) (iv) (iii) (ii) (i)
june 2011
8. If the modulation index of an AM
wave is changed from 0 to 1, the
transmitted power is
(A) Unchanged
(B) Halved
(C) Doubled
(D) Increased by 50 percent
19. In a TV transmission
1. Audio and Video are both
frequency modulate.
2. Audio is frequency modulated.
3. Video is transmitted by SSB
modulation.
4. Video is transmitted using USB
modulation.
The correct answer is
(A) 1 and 3
(B) 2 and 4
(C) 1 and 2
(D) 3 and 4
43. List I
List II
(System)
(Order ofFrequency)
(a) Optical fiber communication
(i) 4 to 6GHz
(b) Mobilecommunication
(ii) 88-108MHz
(c) FMBroadcasting
(iii) 900-1800MHz
(d) Satellitecommunication
(iv) 1014 Hz
Codes are :
(a) (b) (c) (d)
(A) (iv) (iii) (ii) (i)
dec 2011
37. List I
List II
(a) Frequency modulation (i)
Envelope detection
(b) Double sideband suppressed
signal carrier (ii) Companding
(c) PCM (iii) Balanced modulator
(d) Amplitude modulation (iv) Preemphasis and de-emphasis
Codes :
(a) (b) (c) (d)
(A) (ii) (iii) (i) (iv)
(B) (i) (iii) (iv) (ii)
(C) (iii) (ii) (i) (iv)
(D) (iv) (iii) (ii) (i)
June 2012
15. Time-Division Multiplexing
(A) can be used with PAM only.
(B) combines five groups into a
super group.
(C) stacks 24 channels in adjacent
frequency slots.
(D) interleaves pulses belonging to
different transmissions.
16. One of the following types of
noise becomes of great importance
at high frequencies. It is the
Division
Mulplexing
(iii) Hardware
techniques
(d) Frequency
Division
Multiplexing
(iv) Software
techniques
Codes :
(a) (b) (c) (d)
(A) (iv) (iii) (ii) (i)
(B) (i) (ii) (iii) (iv)
(C) (iii) (iv) (i) (ii)
(D) (iv) (iii) (i) (ii)
Dec 2012
15. A 20 kW carrier is sinusoidally
modulated by two carriers
corresponding to modulation index
of
30% and 40% respectively. The
total
radiated power is
(A) 25 kW (B) 22.5 kW
(C) 45.0 kW (D) 35.0 kW
16. ASCII code has 128 characters,
which are binary coded. If a
computer generates 106 characters
per second, then minimum band
width required to transmit this
signal
will be
(A) 1.4 mbps (B) 14 mbps
(C) 7 mbps (D) 0.7 mbps
43. List I List II
a. QPSK i. deviation
b. Hamming code ii. I.F.
c. Superhetrodyne iii. Error
correction
d. Frequency
modulation
iv. 90
Codes :
abcd
(A) iv i ii iii
(B) iv ii iii i
(C) ii iii iv i
(D) iv iii ii i
22. The modulation index of an AM wave
in changed from 0 to 1. The
transmitted power is
(A) unchanged
(B) halved
(C) doubled
(D) increased by 50 percent
23. In a low level AM system, amplifiers
following the modulated stage must be
(A) Linear devices
(B) Harmonic devices
(C) Class C amplifier
(D) Non linear devices
24. Indicate the false statement. The square
of the thermal noise voltage generated
by a resistor is proportional to
(A) its temperature
(B) its resistance
(C) Boltzmann constant
(D) the bandwidth over which it is
Measured
38. Indicate the false statement.
(i) HF mixers are generally noiser
than HF amplifier.
(ii) Impulse noise voltage is
independent of bandwidth.
(iii) In thermal noise, the noise power
generated by a resistor, is
proportional to the bandwidth.
(iv) Industrial noise is not an impulse
type.
(A) (i) and (ii) are correct.
(B) (ii) and (iii) are correct.
(C) (iii) and (iv) are correct.