Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Issue 1
Do not manually back drive the pan or tilt axis by hand. Back driving may strip teeth off the internal gears
and in so doing will void the warranty.
M8 Stainless steel nuts, bolts and washers should be used to secure the base to the mounting surface. Suitable
sealant or a gasket should be used between the camera base and the mounting surface.
Ensure that the 12 pin connector is located into the camera base plug and that the lock ring is tightened. Ensure
that the base compartment containing the 12 way connector is moisture proof. On inverted units it is very
important that the connector area is water tight to prevent water pooling around the connector.
The MiC400 series of PTZ cameras comes with a security attachment point as standard. This should be attached
to a safety chain which in turn should be attached to a secure part of the structure.
Connections between the MIC400 and the MIC-PSU using the MIC Composite Cable:
Note: all connections must be made
MIC400 Composite
Cable Wire Colour
Function
PSU Terminal
Connector
PSU Terminal ID
marking
Red
Green
White
Yellow
Drain Wire
Blue
Violet
Coax Core
Coax Screen
15v AC supply
15v AC supply return
Camera Rx B
Camera Rx A
Gnd
Camera Tx A
Camera Tx B
Video
Video Return
HD3-1
HD3-2
HD3-3
HD3-4
HD3-5
HD3-6
HD3-7
HD3-8
HD3-9
Power
Power
RxB
RxA
GND
TxA
TxB
Video
Vid 0v
Page 2 of 3
BOSCH SECURITY SYSTEMS
Black
Orange
Tamper Switch
Wash
HD3-10
HD3-11
Grey
Brown
0v Tamper Switch.
0v Wash
HD6-1
HD6-2
IR Lamp + or Speaker +
or Heater +
IR Lamp- or Speaker or Heater -
HD6-1
IR +
HD6-2
IR -
IR lamp, Heater or
Speaker Option
Grey
Brown
Tamp Sw
Wash
RS485 + to camera
RS485 to camera
0v from control room.
RS485 to control
room.
RS485 + to control
room.
RXB
RXA
GND
TXA
HD4 or
HD5
Pin 1
Pin 2
Pin 3
Pin 4
TXB
Pin 5
MAINS
Live
Neutral
Earth
HD1-1
HD1-2
HD1-3
VIDEO
Video BNC CN1
Core
Screen
Connection
Video to Control Room
Video GND to Control Room
Please Note:
Cameras are supplied set to address 1, to change the address and configure the camera you will require the
Universal CamSet program and a PC with a serial port and an RS232 to RS485/RS422 adaptor. A PC without a
serial port can use the MIC-USB485 CVTR to connect to the MIC-PSU instead.
Page 3 of 3
BOSCH SECURITY SYSTEMS