Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Combining Transmission
Feature Description
Date
Author
Approved By
Remarks
V8.1.1
2009-03-12
V8.1.2
2009-08-30
TABLE OF CONTENTS
1
Feature Property........................................................................................................ 1
2
2.1
2.2
Overview.................................................................................................................... 1
Feature Introduction.................................................................................................... 1
Correlation with Other Features..................................................................................1
Technical Description...............................................................................................2
4
4.1
4.2
5
5.1
5.2
6
6.1
6.2
6.3
Engineering Guide.................................................................................................... 5
Application Scenario................................................................................................... 5
Configuration Description............................................................................................5
Network Impacts......................................................................................................... 5
Abbreviation.............................................................................................................. 5
Reference Document................................................................................................ 5
FIGURES
Figure 1
Figure 2
Figure 3
II
DPCT Function.............................................................................................................
Configuration Interface 1 of Power Combining Transmission.......................................
Configuration Interface 2 of Power Combining Transmission.......................................
Feature Property
iBSC version: [iBSC V6.20]
BTS version: [Applicable for RF modules whose RU types is RU02 or RU02E in SDR
platform]
Attribute: [Optional function]
NEs involved and requirement
NE Name
Related or Not
MS
BTS
BSC
MSC
MGW
SGSN
GGSN
HLR
Special Requirements:
Overview
2.1
Feature Introduction
DPCT indicates that two transmitters send same bursts in the same moment, and form a
nominal carrier through the combiner, thus enhancing the output power.
The four-antenna diversity receiving function is used with DPCT simultaneously to
implement the ultra-distance coverage of BTS.
This feature can enhance the downlink transmission power, thus expanding the
coverage of the cell.
2.2
Technical Description
DPCT uses two carriers in the double-density carrier module to send the same pulses
simultaneously, and overlap the pulses to implement the output enhancement. See the
following Figure 1.
Figure 1
DPCT Function
The phases and amplitudes of the signals of two channels are identical, and the signals
will be combined in the RF module. Theoretically, because PAs of two channels are
combined into one channel to output, the signal will gain the downlink gain of 3 dB. The
actual gain is 2.5 dB after the deduction of loss of internal combining. DPCT is different
from DDT in this way: DPCT can enhance the power physically, therefore, it is especially
applicable for areas with large-coverage demand.
RU02 selects the module of internal combining, and configure two carriers to one carrier
whose combining output implements the DPCT function.
4.1
Parameter List
None.
4.2
Parameter Configuration
Enter the configuration management interface.
1
In the configuration resource tree window, right click and select OMC -> GERAN
Subnetwork -> NodeB Managed Element -> BTS Config Set -> BTS Radio
Resource Management -> GSM Radio Resource Management -> Create ->
GSM RU Parameter Configuration, as shown in Figure 2.
Figure 2
Click GSM RU Parameter Configuration, and set Function Mode to DPCT in popup GSM RU Parameter Configuration window, as shown in Figure 3
Figure 3
5.1
Related Counters
None
5.2
Related Alarms
None
Engineering Guide
6.1
Application Scenario
When the function is used, at BTS side, it is applicable only for RF modules whose RU
type is RU02 or RU02E in SDR platform. At BSC side, it is applicable for iBSC V6.20 or
above.
6.2
Configuration Description
Select DPCT mode in background configuration.
RU02 should provide the module of internal combining.
6.3
Network Impacts
Impact on network:
This feature can enhance the downlink coverage effectively, and can work with uplink
enhancement technology in scenarios with large-coverage demand to improve the
access performance of cell boundary.
Impact on NEs:
When this function is activated, the capacity of double-density carrier is reduced by half.
That is, if a S222 adopts DPCT, the capacity will changed to S111.
Abbreviation
Abbreviations
Full Characteristics
3GPP
DPCT
Reference Document
[1] ZGF05-01-014 Support Tower Mounted Amplifier
[2]ZGF05-13-004 Four Way Diversity Receiving (FWDR)