0 calificaciones0% encontró este documento útil (0 votos)
1K vistas2 páginas
This document provides instructions for modifying the odometer reading on a Citroen Berlingo BSI NEC using an Enigma tool. It involves:
1. Removing the BSI module and soldering cable C13 to points on the board according to photos 1-3, which includes lifting a PIN and dismounting a component.
2. Checking that the new odometer reading shows correctly after pressing the "READ KM" button.
3. The document warns that the tool maker takes no legal responsibility for any illegal use of the information provided.
This document provides instructions for modifying the odometer reading on a Citroen Berlingo BSI NEC using an Enigma tool. It involves:
1. Removing the BSI module and soldering cable C13 to points on the board according to photos 1-3, which includes lifting a PIN and dismounting a component.
2. Checking that the new odometer reading shows correctly after pressing the "READ KM" button.
3. The document warns that the tool maker takes no legal responsibility for any illegal use of the information provided.
This document provides instructions for modifying the odometer reading on a Citroen Berlingo BSI NEC using an Enigma tool. It involves:
1. Removing the BSI module and soldering cable C13 to points on the board according to photos 1-3, which includes lifting a PIN and dismounting a component.
2. Checking that the new odometer reading shows correctly after pressing the "READ KM" button.
3. The document warns that the tool maker takes no legal responsibility for any illegal use of the information provided.
FOR MORE INFORMATION Call 0034 983 359 787 or visit www.enigmatool.com DIAGCAR ELECTRONICS S.L. Ebanistera 1A, 47610 Zaratn, Spain
PHOTO 1: Solder C13 cables according to the colors like shown on the photos above.
BSI AND LOCATION: REQUIRED CABLE(s):
C13 + A1
FOLLOW THIS INSTRUCTION STEP BY STEP: 1. Remove the BSI module and open it carefully. 2. Solder cable C13 to the points on board as shown on PHOTO1. 3. Solder cable C13 and lift PIN like shown on PHOTO2. 4. Solder cable C13 and dismount component like shown on PHOTO3. Put component back when the job is done. 5. Make sure that the connection you made is secure. 6. Press the READ KM button and check if the value shown on the screen is correct. 7. Now you can use the CHANGE KM function.
E N I G M A U S E R M A N U A L CITROEN BERLINGO BSI NEC FOR MORE INFORMATION Call 0034 983 359 787 or visit www.enigmatool.com DIAGCAR ELECTRONICS S.L. Ebanistera 1A, 47610 Zaratn, Spain
PHOTO 2: Solder C13 cables according to the colors like shown on the photos above. Remember to lift up one PIN like shown on photo above.
PHOTO 3: Solder C13 cables according to the colors like shown on the photos above. Remember to dismount component shown on photo above and to put it back when the job is done.
LEGAL DISCLAIMER:
DIAGCAR ELECTRONICS S.L. does not take any legal responsibility of illegal use of any information stored in this document. Copying, distributing or taking any action in reliance with the content of this information is strictly prohibited.