Está en la página 1de 168

Andrea's Rose - J.C.

Nolan 9/25/91

C
A

5. To complete the base,


do the same with C & D.
A B

A B

9. Fold the spread-squash back up 10. Now, repeat steps 8-9 on the
11. Repeat the sink on
on the existing creases, pulling one next corner. Note the placement of
the last two corners.
layer from each side inward and fingers. Be careful when folding the
upward. sink back up, it is as easy to grab
two layers as one.

12. The second level of sinks is complete. 13. Note that the squashed 14. Complete the level by sinking
The model should be symmetric in four square is always in the center the other 3 corners.
directions, if it is not, then a mistake was of the model.Fold up as
made in folding up the sinks. Continue before.
sinking on the next level.

15. Keep adding levels until your 16. To complete the model,
paper shreads irrecoverably, your valley fold the last set of flaps 17. Completed model.
eyes explode, or you feel satiated towards the center, and pull the
by the process. As a challenge, I flaps out from behind.
recommend eight levels on an 10"
piece of paper.
Diagrammed by J.C. Nolan - Oct.'92
Angel Maarten van Gelder  1986 Sep Q

This angel has coloured wings and a white face and dress. When folded from
soft coloured paper you may create a nice mobile for Xmas.
K K L
F
L Q Q L
Q
F

R R
1 Start with waterbomb- 2 3
base (color inside). L
F F R

11 Fold points R to K. Points 12 Raise flap F. The mountain fold


Q flatten automatically. through R is only in one layer.

4 5 Fold point backwards. 6 L


After that turn model
inside out. See diagrams 6 and 7 for the result. F

F R

Q
Q Q
L
Q Q
13 Repeat on left side. 14
Turn model over.
7 Fold white point (head) up. 8 Fold point down.
Points Q will raise. Don’t Points Q stay up.
push flat; they will flatten
automatically in diagram 11..13!

Q Q

Q Q

15 Fold upper edges 16 Detail: 17 Fold like


9 Fold two flaps so that they 10 of the wings between head the preli-
will overlap. See diagram 14 the layers. minary fold.
for the position of the wings. Fold point down.
Turn model over.
16

18 19 Front: Turn head 20 Unfold the head back


flap over to the to diagram 16. Keep
front. front up.
26 27 Curve the wings
to get a nice result.

Back Front

21 Push sides of head 22 23


in. Folds in the front
of the head remain as they are, folds on the back turn from valley
to mountain and vice versa. Top will become 3D. Push flat to diagram 23.

24 25
Angel created & diagrammed by Alec Fehl

3] Inside petal fold. (Petal fold,


1] Colored preliminary fold. 2] Squash fold. Repeat on then tuck the triangle underneath.)
back and sides. Repeat on sides. DO NOT
repeat behind.

4] Reverse fold point up. Repeat on right. 5] Turn over.

6] Tuck bottom flap inside. Crimp head.

7] Tiny reverse fold at base of head.


Repeat on right and behind. Turn over. 8] Reverse fold bottom corners. 9] Valley fold wing over.
Squash fold the wing.

The completed angel


10] Valley fold side of wing to the left. Fold 11] Repeat 8-10 on other wing.
other side to the right. They will overlap. Tuck 3-D head by pulling out 4
one flap into the pocket to lock the wing. trapped ridges. Turn over.
(Tuck flap into pocket .)
JacAlArt ©1996 Angel
Bebé Parasaurolopus

Fernando Gilgado Gómez

1 2 3

4 5
6

8 9
7
10

11

12

13

14

15
Sacar la
punta que está
16 dentro

17

18

19
$ “One-Way” Arrow
Copyright 1998-99 Stephen Hecht. All Rights Reserved
A dollar bill makes a model 100mm long and 32mm wide.
Rectangles of other dimensions may also used, provided they are “considerably” longer than they are wide.

1/4

1. Start with the “ONE” side


up. Crease at eights, but not 2. Starting the “point” of the
sharply on the middle crease. arrow. Valley-fold. 3. Fold and unfold through
Turn over and rotate 1/4 either all layers. Repeat on right.
way (depending on which way
you want the arrow to point).

4. Pleat. Make the 5. Reverse-fold 6. Reverse-fold the 7. Valley-fold all


valley-fold first. Then corners at 45 degrees. long edges, closed- layers on existing
bring the mountain- Easiest to bring long sinking at the top crease.
fold to the indicated edges to center, corners. Start at
intersections. squashing the corners, the open end and
then close up. work up.

1/2

8. Reverse-fold other 9. “Point” finished. 10. Begin working


corner on existing Rotate to other end on the “flights”. 11. Sink inside.
creases, tucking into and turn over. Reverse-fold top
triangle on left. The layers.
tiny valley-fold at the
right edge helps make
the tuck easier.
$ “One-Way” Arrow (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

12. Swing out the raw 13. Reverse-fold. 14. Swing down. 15. Wrap a single ply
edges from behind. Repeat on left. around the central
Model is not flat at the trapezoid. Easier if
“point” end. you open the model
up considerably.

16. Pleat. First mountain-fold


along bottom of trapezoid. 17. Swing side strips in to
Then valley-fold to line up with middle. Model not flat at
indicated edge. Unfold pleat top; concave “ear” shapes 18. Valley-fold top layer,
and turn over. form. between pleat lines, which lifts
the “flights” perpendicular.

19. Continue flipping over 20. Like so. Model is 21. Tuck the new upper
the “flights”, squashing a now flat. Turn over. trapezoid inside the one
new trapezoid beneath the behind it, which was wrapped
one you wrapped earlier. earlier.
$ “One-Way” Arrow (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

23. Pleat and tuck under diagonal edges.


22. Flip the tail assembly down. Gently bend the model along the vertical with
a mountain-fold to facilitate the tuck. Then
flatten out to secure.

ONE
24. Finished.
$ Heart-and-Arrow
Copyright 1999 Stephen Hecht. All Rights Reserved
A dollar bill makes a model 30 mm x 45mm. For your first attempt, begin with a 3x7
rectangle larger than a dollar bill.

B A

1. Either side up. Crease at 3. Use the mark to make


2. Make this crease sharp crease “A”. Then use “A” and
eights horizontally, halfway only where it crosses the
vertically. Flex all creases both the center vertical line to make
center horizontal line. crease “B”, at the same
ways.
distance. Flex both.

4. Horizontal creases not 5. Bisect the outer rectangles. 6. On each side, use the outer
shown. Bisect the rectangles. 2 creases to add another.

center
line

7. All creases shown. 8. Swing behind on the 9. Flip down the top eighth,
Mountain the top and bottom indicated crease. Turn over. squashing the corner at the
eighths behind. right.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

10. Pull out paper from under 11. Swing over the long
flap, while pulling up the 12. Swing flap back on
the squash, flipping down the existing crease, while flipping
long edge. triangle shown.
down the top eighth and
squashing a tiny diagonal.

15. Pleat and sink on


13. Swing back. Both sides 14. Crease. existing creases.
of model will then look similar.

##-##

16. Undo last step. Turn


over and repeat 14-16. 17. Crease top flap. 18 . Reverse-fold on
Repeat behind. existing crease. Turn over.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

19. Reverse-fold on the 20. Swing flap to left on


crease; rear-half is double existing crease, squashing
thickness. only the tiny diagonal 21. Segment “C” is the new
indicated. The X-ray line is crease. Swing back down on
a hidden valley fold. existing crease, squashing the
diagonal shown. The X-ray line
is a hidden valley fold.

22. Fold the new flap to 23. Reverse-fold at the top,


the right. 24. Pull gently open at the
closed-sink at the bottom. top, and reform the sink
from step 15 .

20-24
27. Swing flap to the left,
25. Repeat 20-24 behind. 26. Reverse-fold. At the left squashing the corner behind it.
end, only the embedded layer
is reverse-folded.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

28. Swivel again. Note the 29. Flip up an edge, opening


the triangular pocket. 30 . Closed-sink the small two-
tiny squash (mountain-fold). toned trapezoid. Then swing
the pleated flap to the right.

26-31
32. Swing the large, hidden
31. Swing down 2 edges, triangular flap upwards, 33. Reverse-fold the
swiveling under the sunken reverse-folding the left side. middle triangle upwards.
area. Repeat 26-31 behind.

head tail

34. Valley-fold it back down,


into the pocket immediately 35. Reverse-fold the top 36. Like so. Now we begin
in front of it (a tight fit, even point down, tucking the tip on the tail of the arrow.
if accurate). Turn over. into the pocket immediately
in front of it.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

37. Tail: notice pleats 38. (Not all edges shown.)


are not perfectly Swing over. 39. Rotate.
symmetric. Reverse-
fold.

37-40
40. Bring one layer to 41. Thus. Turn model over
surface (a closed-sink). 42. Repeat 37-40, treating the
top-to-bottom. double-thickness as one layer.
Turn back over (top-to-bottom).

43. Tuck in the loose triangle. 44. Reverse-fold protruding


edges as if they were a single 45. Pull out paper and swivel
edge. down the front edge. The X-
ray line is a horizontal valley-
fold that becomes a vertical
mountain-fold flush with the
right edge of the model.

46. Swing the middle triangle


down and behind, dragging 47. Tuck the loose triangle into the second
the upper triangle. pocket (between pleats, not into the sink).
Tail complete. Turn over side-to-side.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

48. Head of the arrow.


Pleats are symmetric. 49. (Not all edges shown.) 50. Pull out corner.
Reverse-fold first 2 corners. Swing 2 flaps to the left.

51. Like so. Turn over top-


to-bottom.
53. Reverse-fold the
52. Valley-fold top corner. remaining corner; its rear half
Reverse-fold next corner. is smaller than its front.

49-50

54. Repeat 49-50. 55. Swing rear half of large 56. Tuck new flap into pocket
triangle to front. behind. Front edges of
arrowhead are now both
closed.
D

58. There are now 3 tiny


triangular flaps at the tip. Wrap
the top layer of the front triangle
to its back. Very hard! Unfold
point D and 3 pleats of the shaft
while executing.
57. Squash. Turn over top-
to-bottom and repeat on the
other side.
$ Heart-and-Arrow (cont.)
Copyright 1999 Stephen Hecht. All Rights Reserved

tweezers
help

59. Tuck the middle and rear


points inside the front point 60. Left upper point of the heart.
(sequentially or nested). Crease and flex. Then open 61. Top view. Sink the tip on
Arrowhead complete. out the tip into a 3-sided the crease just made (keeping
pyramid, the 2 front right edges the double-edge together).
kept together.

tweezers
help

62. Back to a front 63. Reverse-fold the corner back up, tucking
view. Reverse-fold into the tiny pocket. These steps achieve a
nested corner down. closed sink more easily. Repeat 60-63 on
the right point of the heart.

64. Model complete. Bend arrow head and


tail outwards where they emerge from the heart.

There are unfortunately 2 separate points at the bottom of the heart, but this does help the model
stand up a little better. And though I regret the two-tone harlequin-esque finish, it’s not as glaring
with a real dollar bill as in these diagrams. (I regard these shortcomings as the price of achieving
my self-imposed goal: the arrow shaft emerges from under the planes of the heart.)
Badger
1 2 3

4
5 6 7

8 9 10 11

Repeat steps 4 to 9 on
12 the left side
13
14
15

Crease tip down just a little


below the point behind Crease a single layer
down to half way between the
two horizontal creases
Inside reverse folds Wrap one layer to the front
(colour change)

16 17 18

© Robin Glynn September 1998


Badger
19 20 21

Fold sides towards the


base of the 'imaginary' square

22 23 24 25

26 27 28

90º

31
30
29

33
32

Make 4 inside reverse folds

© Robin Glynn September 1998


Balloon with basket Maarten van Gelder

1992 Aug

1 Mark point 2

3 4 5

6 7 8
Balloon with basket Maarten van Gelder 1992 Aug

9 10 11 Round corners of balloon


Bee by Marc Kirschenbaum

1.Begin with a bird base, colored 2.Precrease the top. 3.Precrease through the
side out. Fold the top flaps intersection of creases.
down.

5-6

4.Sink the top. 5.Spread squash. 6.Flatten. Repeat steps 5-6


behind.

7.Swing the front flap up. 8.Valley down. 9.Valley up.


8-10

10.Unfold. 11.Repeat steps 8-10 in mirror 12.Swing down while spreading


image. out the top layers.

13.Rabbit ear. 14.Squash. 15.Valley over.

16.Swing up. 17.Spread squash. 18.Swing over.


18-19

19.Pull the flap through. 20.Repeat steps 18-19 in mirror 21.Bring the colored layers to
image. the surface.

22.Swing down. 23.Tuck flap into pocket. 24.Swing the large flap over.

8-16

25.Carefully fold flap up, 26.Repeat steps 8-16 on this 27.Swing over.
releasing the trapped layer. flap.
24-27

28.Repeat steps 24-27 in mirror 29.Turn over. 30.Wrap a single layer around
image. each side.

31.Valley up. 32.Unsink. 33.Valley up.

34.Turn over. 35.Swing everything over. 36.Swing down two flaps.

37.Closed sink. 38.Swing one flap up. 39.Swing the large flaps back.
35-39

40.Repeat steps 35-39 in mirror 41.Swing one flap over. 42.Swing one flap up (a portion
image. of the fold is hidden under
the colored region).

43.Swing up again. 44.Swing the flap through. 45.Reverse fold.

46.Rearrange the flaps as 47.Swing up while incorporating 48.Swing over bottom flap.
indicated. a reverse fold. Stretch top flap outwards.

49.Swing down two flaps. 50.Swing over one flap. 51.Valley corner down.
41-51

52.Repeat steps 41-51 in mirror 53.Swing down. 54.Valley up.


image.

55.Swing down. 56.Precrease in opposite 57.Valley to horizontal crease.


direction.

58.Valley to center. 59.Unfold. 60.Swing up while swiveling in


sides.

61.Precrease. 62.Valley the top single layers 63.Valley the tail up.
outwards while folding the
tail upwards. The tail will not
lie flat.
64.Pleat the tail. The valley fold 65.Fold the sides back to the 66.Precrease. The resulting
lies along an existing crease. center. A swivel will form width should be about as
The mountain fold is midway underneath the pleat. wide as the colored section
from the valley fold to the below.
white portion.

67.Squash the tip. 68.Swing the top back to reveal 69.Valley upwards; do not
the colored triangle. crease sharply.
Mountain back the excess
paper at the base ofthe tail.

70.Swing the top flaps up. 71.Reverse fold. 72.Swing over.


73.Valley up. 74.Swing over. 75.Sink.

76.Swing back. 77.Swivel over. 78.Pull out single layer.

79.Swing over. 80.Rabbit ear. 81.Swing over.

72-82

82.Swing over. 83.Repeat steps 72-82 in mirror 84.Lightly fold the model in half.
image.
1/4

85.Squash flap, being sure to 86.Reverse fold one half into 87.Swing over.
distribute the inner layers as angle quadsectors. Reverse
evenly as possible. The tiny the other half along the angle
hidden flap should go bisector.
towards the head. Rotate.

85-88

88.Squash fold. Repeat steps 89.Reverse fold. 90.Swivel up. Make the valley
85-88 behind. fold as light as possible.

89-92 Edge A

91.Valley fold. 92.Swing over two flaps. Repeat 93.Ccrimp the head into the
steps 89-92 behind. body so that edge A lies
straight. Alow the antennae
to swing up.

94.Valley fold. 95.Pull out back leg while 96.Valley down.


swiveling at top.
94-97

97.Tuck the tip of the win into 98.Rabbit ear the front legs. Due 99.Crimp the middle legs in half.
the pocket. Shape the wing. to the thickness, they will
Repeat steps 94-97 behind. stick out slightly.

100.Pull the antennae back and 101. Curl the antennae around 102.Crimp the legs. Curl the
outside reverse fold the the head. Double rabbit ear antennae and the tip of the
head around them. the head. Pull tail upwards. head.Round out the
abdomen, and curl the
wings around it.

103.Completed Bee
©1994 Marc Kirschenbaum
Beetle Created by Marc Vigo Anglada
April 1994
Beetle, Page 1 of 3

1 Begin with a 2x1 rectangle 2 3 4 Valley fold front layer, reverse


Fold two waterbomb bases fold the rest, as swhon in figure 5

6 Valley fold front layer, reverse fold 7 Sink three corners


the rest. Repeat on the right side Repeat on the right side

8 Front view. Mountain fold inside 9 The result shoud look like this 10 Raise the corners. All oblique pleats
Repeat on the right side Turn the model over are at 45 degrees.
Created by Marc Vigo Anglada Beetle, Page 2 of 3
April 1994

11 Sink. Repeat on the 12 Turn the flap to the left 13 Valley fold front layer,
right side Repeat on the right side reverse fold the second.

14 15 Mountain fold first layer, 16 Reverse fold


valley fold the second

17 Repeat steps 12-15 18 Turn the model over 19 Mountain fold


on the left side two layers

20 21 Pleat fold to form


the head
Created by Marc Vigo Anglada Beetle, Page 3 of 3
April 1994

22 Valley fold the eyes 23 Turn the model over 24 Rabbit ear the first
pair of legs

25 Rabbit ear the second 26 Valley fold one layer 27 Reverse fold middle legs
pair of legs to lock the model Rabbit ear third pair of legs

28 Crimp fold tip of legs


Mountain fold in half to
mark wings ’94
Cup Maarten van Gelder  1987 Oct
Cup with variations
First make the simple one

1 2 3

4 5 Turn/click in position

7 Variation 1: divide in 8 8 9

10 Make round and then 11 Variation 2: divide in 16


slide in the overlap Very difficult to form cup!
Variation 3: divide in 32; very, very difficult
And the thicknes of the paper is coming in
The Belle Damsel
By Perry Bailey on request by
Valerie Vann.

1. Use foil paper for best effect on this model, While you could
use kami, it will be more difficult and not as nice looking.
Start with 1/2 of a square or 2:1 ratio piece of paper, large
paper is not needed as a 6X3 piece of foil works well. Fold
the foil into sixteenths, with skin color desired on the out side.

2. reverse fold in
the first 2 corners
on each side.

4. reverse fold
down the top from
the center fold to form
the head.

3. pull down the pleats


to form the arms.

page 1 of 2
5. open up the figure and
pull up the first layer of the
head while flatening the inside
flaps to effect a color change.
This will give your model the same
color hair as her gown.

6. Inside rabbit fold


both arms, then fold
a small part of the
hair back under to
give her a face.

7. This is where all I know how to do is give


a description. fan the model outwards at the
bottom, while holding the top down to just
below the arms. then use your thumb to inside
of the model and wrap the pleats all the way
around like a bell. the two ends of the foil will
overlap. At that point make the dress as full
or small as you like. To lock the bottom together
just fold up a little of the bottom or hem of the
dress upwards. and you are done.

Finished
looks best
when small.

page 2 of 2
Big Bird

1 2 3

4
5 6

45º

7 8 9 10 11

Repeat steps 5 and 6 on the


Fold 1 layer to the right (front
other 3 sides
Fold 2 layers to the left and back to even up the
layers on each side)
12 13 14
15
16

180º

Squash fold
Fold 1 layer to the top Valley fold the 2 small points. asymetrically or see the
Note that the lower edges are box below
slightly above the centre crease

An alternative is to squash fold Much harder still, if you form tiny


symetrically, this is a bit fiddly 'bird bases' on the centre layers,
but the eyes will eventually look the eyes turn out like this
like this

Diagrammed by R.Glynn © July 1999


Big Bird
17 18 19 20

Make 3 small mountain


folds to round off each eye

Swivel a point to the left so Swivel the other point to Valley fold the three points
that it continues the line of the right to the centre
the bottom edge

22 23
21

Unfold

Inside reverse fold the 3 points Make small valley fold


to form feathers

24 25 26 27

Valley fold the point up note that Make 2 sharp creases about These creases should be made
the horizontal crease is slightly half way to the centre line lightly, just bending the paper
above the existing diagonal crease

28

Gently squeeze the sides to make


the beak open and close

Make the beak 3-dimensional,


gently curving the head back

Diagrammed by R.Glynn © July 1999


Dollar Bill $
Model Created and Diagrammed by A. Anselmo 12/93
(although I’m certain someone has done something like it.)
anselmo@thermsa.eng.sunysb.edu

3) Fold along 4) Unfold the 5) Keep the right


1) Fold the bill 2) Fold edges the indicated left side. The object hand side together,
lengthwise, and towards the lines. of the next few folds and fit the pocket
unfold. Fold edges middle again. is to create a locking forming at "A" into
in to the middle. mechanism. the shaded tab.

A valley 8) Lay the fold sideways, and make it into a reversed


"S" shape with a series of valley and mountain folds.
valley Of course, when looking at it unfolded, all the folds
mountain appear as valley folds. The reverse "S" here is shown
a bit more "open" than I usually make it. The tighter
valley the "S", the more of a tail you will be left with to make
mountain the vertical line that goes through the "S". Take note!

6) How the fold 7) This should 11) This.


progresses. be locked by Valley fold
now. upwards at the
indicated point.
I 10) Mountain fold
only the top flap to 12) Valley fold
O the left to achieve... and mountain
O
fold so this last
piece can collapse
I
towards you.
9) Unfold the last
16) Valley
valley fold. Make
fold upwards,
the folds "I" inside 14) Now you under the middle
reverse folds, and "O" should have and over the top.
outside reverse folds, this. Fold this
so the reverse "S" shape long flap to the
will not come apart. left.
17) You should
have this now.
Flip it over, and
15) Valley you have a
13) You should fold the flap "Dollar $" !
only follow the so it hangs
indicated folds downwards.
to collapse this Note: This model appears best
section. after sitting in your wallet for a few hours,
since the creases have time to set.
Biplane II by Marc Kirschenbaum (NY) ©1996

Complex
A 10" square makes a model with a 4" wingspan

1. This will be the color of the 2. Valley the corners to the 3. Pleat along existing creases.
body. Precrease along angle intersections of creases and
bisectors. unfold.

4. Valley to center. 5. Turn over. 6. Fold sides to center, allowing


flaps to swing outwards.

7. Unfold entirely. 8. Collapse. 9. Squash the center flap.


9-10

10. Valley down as far as 11. Spread open to reveal small 12. Sink triangularly halfway.
possible and unfold. Repeat flap.
steps 9-10 behind.
12-13

13. Close back up. Repeat steps 14. Petal fold. 15. Valley to intersection of
12-13 on the other side. creases.

14-16

16. Precrease sides of flap and 17. Valley corners. Turn over. 18. Swing a flap over, front and
then open up. Repeat steps back.
14-16 behind.

19. Precrease through all layers. 20. Unfold bottom flap. 21. Squash. Do not flatten
completely.

22. Wrap around to make 23. Pull out single layer. 24. Valley over.
symetrical.

23-26 18-26

25. Reverse fold. 26. Swing over flap while 27. Repeat steps 18-26 in mirror
incorporating a reverse fold. image.
Repeat steps 23-26 behind.
28. Valley up corners. 29. Pull out hidden corners. 30. Pull out hidden points.

31. Crimp sides. 32. Valley down four points. 33. Stretch apart sides.

33-34

34. View from step 33. Double- 35. Repeat steps 33-34 on other 36. Lightly swing up top section.
crimp upwards and flatten. side.

36-37

37. Swing back down while 38. Repeat steps 36-37 behind. 39. Swing down flaps.
collapsing the top single
layer outwards.
40. Swing over a layer, undoing 41. Wrap around a single layer. 42. Swing back. Repeat behind.
reverse fold. Repeat behind. Repeat behind.

43. Pull flap out, releasing layers 44. Asymmetrical squash. 45. Valley layer through. Repeat
at left. Repeat behind. Repeat behind. behind.

46. Swivel down. Repeat 47. Swivel over. Repeat behind. 48. Bring single layer to surface
behind. (closed sink). Repeat
behind.

49. Sink triangularly, so as to 50. Sink triangularly again. 51. Wrap around a single layer.
match up with the folded Repeat behind. Repeat behind.
edge in the middle. Repeat
behind.
52. Swing flap over while 53. Swing over two layers. 54. Pull out single layer from
incorporating a reverse fold Model will not lie flat. behind.
along existing creases.

55. Swivel under. 56. Swing single layer back. 57. Swivel up.

52-59

58. Wrap single layer around 59. Close model back up. 60. Repeat steps 52-59 behind.
(closed sink).

61. Swing over flap while pulling 62. Valley along existing crease. 63. Swivel down hidden middle
up a layer through the Repeat behind. layer into pocket. Repeat
pocket. Repeat behind behind.
64. Bring single layer to surface 65. Closed sink along existing 66. Pull point outwards.
(closed sink). Repeat crease. Repeat behind.
behind.

67. Bring the bottom points to 68. Swing down. 69. Precrease. Repeat with
the top, allowing the corners adjacent flap.
to spread sink.

70. Spread apart. 71. View from step 71. Sink 72. The edges of the wing
single layer through from should now be flush. Close
behind, using the creases the model up.
from step 69.
68-72

73. Repeat steps 68-72 behind. 74. Sink triangularly along 75. Closed sink along existing
existing crease. Repeat crease. Repeat behind.
behind.
76. Outside reverse fold along 77. Detail of tail. Valley along 78. Unfold.
existing crease. angle bisectors.

Point A Point A

79. Swivel fold. Repeat behind. 80. Crimp upwards, so point A 81. Valley down. Repeat behind.
meets colored raw edge.

82. Valley along angle bisector. 83. Swivel over. Repeat behind. 84. Valley up. Repeat behind.
Repeat behind.

85. Mountain top flaps into 86. Mountain the double layer 87. Reverse fold back. Repeat
pocket. about 1/4th the width. behind.
Towards the tail, the fold will
terminate at an angle, and
at the other end, a swivel
will form. Repeat behind.
88. Mountain behind wing. 89. Valley to existing crease. 90. Crimp the tail section. See
Repeat behind. Repeat behind. step 91 for positioning.

91. Collapse upwards. 92. Outside reverse fold. 93. Sink the indicated regions.

94. Reverse fold the indicated 95. Valley over a single layer. 96. Pull the center flap fowards
areas. Repeat behind. while pulling the side flaps
outwards.

97. Open sink. 98. Reverse the four hidden 99. Reverse the first of the three
corners down. points down. Note how the
bottom five layers are
distributed.
99-101

100. Swivel. 101. Reverse into pocket. 102. Swivel.


Repeat steps 99-101
behind.

103. Tuck the bottom hidden 104. Spread apart the flap flat, 105. Valley down.
points into the center of while pulling it into an
the model. upright position.

106. Valley up. 107. Valley down. 108. Undo pleat.


106-108

109. Repeat steps 106-108 in 110. Asymmetrical squash. 111. Squash.


mirror image.

112. Pull out single layer. 113. Squash. 114. Precrease.

115. Rabbit ear. 116. Unsink. 117. Swivel up.

118. Valley over. 119. Swivel. 120. Mountain behind.

121. Mountain behind. 122. Flip the points. 123. Valley through intersection
of creases. See step 124
for positioning.
124. Spread squash. 125. Swivel at each side. 126. Swivel at right. Bring
colored layer to surface.

127. Pleat downwards. 128. Completed propeller. 129. Valley up (there are no
reference points).

129-131

130. Pull the single layer up as 131. Pleat the excess into the 132. Repeat steps 129-131
far as possible. center pocket. behind.

133. Sread the wings apart, 134. Collapse the sides inwards 135. Completed cowl.
allowing the front to spread at 90º. You can trim the
apart too. To flatten, fold sides to taste with
the top of the cowl over. mountain folds.
136. View of lower wing. 137. Valley at 45º 138. Wrap a single layer 139. Squash over.
Precrease. through intersection around.
of precrease and
center.

140. Wrap a single layer 141. Spread squash. 142. Rabbit ear the tip of 143. Raise the wing and
around. the strut. strut, tucking its tip
into the pocket on
the upper wing.
Repeat steps 136-
143 on other wing.

144. Detail of landing 145. Valley up. 146. Pull out a single 147. Valley down while
gear. Precrease. layer from each incorporating
side. reverse folds.

148. Shape with 149. Round off with 150. Completed wheel.
mountain folds. mountain folds. Repeat steps 144-
149 behind.

151. Completed Biplane II


©1996 Marc Kirschenbaum
Bird
Designed and diagrammed by Andy Carpenter 1998.

Use a square of thick paper or foil backed paper. An


11 inch square will produce a model approximately
8.5 by 3 inches.

3. Fold left side of model over as shown.


1. Precrease with a diagonal 2. Continue precreasing. The new mountain fold should be placed
valley fold and divide the sides such that the paper folds flat.
into 1/8's.

6.
4. 5. Repeat step 3 on right side of paper.

8. The valley fold at the bottom 9. Folds at the top and bottom trisect
7. Valley fold downwards to
bisects the angle. Lift the flap the angle. The fold on the right
form a flap. The paper
back upwards to form a bisects the angle.
should lay flat.
triangle.

Copyright Andy Carpenter (1998)


10. Repeat steps 7 - 9 on the left 11. Turn the paper over and make the 12. First mountain fold the paper
side of the paper. The model will folds shown. The folds were formed in behind at the bottom to form the tail.
not lie flat after this. step 2. Then mountain fold the paper in half.

13. Side view of bird. Crimp the paper.


14. Turn the paper over to see it
from the underside.

15. Pull the paper out where the


arrows are.

17. Enlarged view of left leg from 16.


Thin legs by valley folding top half and 18. Enlarged view of left leg. Valley fold
sink folding lower half. Leg should stand the leg over from right to left. Repeat on
16. The paper should look like above
up. Repeat on the right leg. other leg.
(or at least similar).

Copyright Andy Carpenter (1998)


19. Crimp the neck. 20. Shape the head as above. 21. Form the beak.

24. Spread out the paper


22. The model should look as above. on the foot as much as
23. Enlarged view of one of
the legs. Crimp the leg and possible.
repeat on other leg.

25. Enlarged view of spread out foot


26. Enlarged view of tail area only. Fold to shape tail feathers.
from the underside. Fold to form three
claws. Tweezers may help here. Repeat
on other foot.

28. The completed bird. With some manipulation of the tail and
27. Fold to shape bird as shown.
feet it should be possible to balance the bird on its feet.

Copyright Andy Carpenter (1998)


Copyright Andy Carpenter (1998)
Bird of Paradise c Ronald Koh - 1973

1. 2. 3.

Begin with an equilateral Fold to the crease line in the ... and turn paper over.
triangle, about 15 cm to each centre ...
side. Fold and fold.

4. 5. 6. 7.

C C
A

B B

In this step, only the Mountain fold each of Fold in half. Imagine BCD as an
top layer is folded. the corners under as isosceles triangle.
Bring the lower edges shown, at the Valley fold as
to the middle. mid-point between A illustrated and
and B and parallel to crease well.
line B and C.

10.
.8 9.

Fold down and crease ... then unfold Steps 7 Reverse fold along the crease
well ... and 8. lines made in Step 7.

11. 12. 13.

Reverse fold again along Fold and unfold, creasing ... then valley fold to the crease
creases made in Step 8. firmly ... made in Step 12.
14. 15. 16.

Fold over ... ... and over. Repeat Steps 12 to 15 on


the other side.

17. 18. 19.

Outside reverse fold on the left ... ... and then the right, at the Fold up the top and back
angle as illustrated. pieces as shown.

20.

21. 21.

Rabbit's ear. Mountain fold the ... and reverse fold


Repeat at the back. corner on the left, again.
repeating behind. Steps 22 to 24 are
Reverse fold on the close ups of the
right ... head.

22.
Outside reverse at the top while
crimp folding below ...

23.

... like this. Sitting pretty!


Make two consecutive reverse
fold to form the beak ...
24.

... then crimp fold


here to finish.
Black Belt in Origami
2
1 3 4

Preliminary fold

7
6
5

Fold the point up inside the model


(you need to pull the model apart
Pull out the loose paper (it helps to do this)
if you unfold to step 4 first)

8
9 10 11

This is the half way stage

12 13 14 15

Repeat steps 3-8 on this side

17 18 19 20
16 Swivel the
point to the
left

See step 20 Line shown


in step 18

Fold the point up inside the model


(much harder than step 7!) Diagrammed by R.Glynn © February 1999
Black Belt in Origami
21 22 23 24 25

Tuck inside

Repeat steps 20-21 on the right Closed sinks Wrap the double layer
from behind to the front

26 27 28 29

Crimp Sqash to form feet

30 31 33
32

Mountain fold
shoulders, neck and
Tuck into pockets behind Crimp Release trapped paper head simultaneously
from behind

34 35 36

37

Diagrammed by R.Glynn © February 1999


Boat III © 1997 Sy Chen
Designed in 4/97 and diagrammed in 5/97;
A variation from Sy's Boat II but effectively
taking advantage of rectangle shape
1. Start from rectangle (3x4, A4, 3. Fold 3 corners
2. Enlarged; Fold and unfold
letter-size, or most of the magazine
papers) with boat color up; Fold
right side; Fold and unfold left side

6. Repeat steps 2-5 for left


4. 5. hand side

7. Open to form 3D 8. Finished


* Ready for variation? Try to make this
one.
B B

A
A C

C
1) Crease on inticated 2) Fold so point 3) Unfold
Start with Specially
Or Make your own by lines. A lies on line
Made 2 toned paper.
mountain and valley BC
folding.

A B
A B
A B

D C C
D
D C
5) fold top back. Midway through 8) Inside
4) Repeat 2 & 3 6) grasp points A 7) Fold and
step 6. Reverse.
symetrically on & B and swing down Unfold.
the left side. so piont C & D meet.

Back Side. Front Side.

9) The result. 10) Fold and 11) fold under 12) Tuck the
turn over. Unfold and tuck in two triangles
pocket. into the pocket,
do not tuck in
pointer underneath.

Book Mark 1 by Kim Best Email -- Kim.Best@m.cc.utah.edu


Start with Specially 1) Make a preliminary 2) Valley fold front 3) Valley fold front
Made 2 toned paper. fold. layer only. layer only.
Or Make your own by
mountain and valley
folding.

4) Unfold to step 2. 5) Tuck underneath. 6) Two reverse folds. 7) Fold and unfold. 8) Two reverse folds.

11) Tuck the Back Side. Front Side.


9) Fold and unfold. 10) fold under two triangles
and tuck in into the pocket,
pocket. do not tuck in
pointer underneath.

Book Mark 2 by Kim Best Email -- Kim.Best@m.cc.utah.edu


1) Crease diagonal 4) Valley fold 5) Turn over 6) collapse
2) Rabbit ear 3) Squash fold
small flap and and blintz. along the
One-fifth of creases.
crease diagonal
the way in.

8) Like this. 10) Two valley 11) (Top portion 12) Tuck in
7) A type of 9) (Top of front
Turn over. folds. only shown) Pockets below.
petal fold. cut away) Make
Two swivel folds.
another odd
petal fold.

13) Open up pocket


Back Front
on the bottom. 14) 15) Step 14
and 15 are to
secure pocket.

Heart Bookmark by Kim Best Inpired by the Heart


Models by Francis OW

email -- Kim.Best@m.cc.utah.edu
Created during the CDO convention December 1995 in Vicenza

1 2

3 4

5 6
7 Model becomes 3D 8

9 Put flap under 10 Form foot


Repeat step 7-9 on other points
Braided Paper - J.C. Nolan 2/13/92
High Intermediate difficulty level. A 10" piece of paper produces a 3 3/4" model.

1. Fold and unfold laterally. 2. Fold and unfold in fourths. 3. Fold and unfold. Turn over.
Turn over.
B

B C

A A

4. Following the existing creases, 5. To complete the base, 6. This is a completed windmill
start to fold a windmill base, bringing do the same with C & D. base. Sink all four corners.
points A and B to the center.

9. No longer an X-Ray view.


7. X-Ray view, reverse fold 8. Pleat sink the two flaps. Pull point A all the way down
the two flaps. Repeat on other Repeat on the other three as far as it will go, thinning the
three sides. sides. diagonalsas you fold.
B

B
B B
B
A A A

D
C
10. Repeat on the next flap. 11. Repeat on the next flap. 12. Repeat on the last flap, tucking
Point A will become covered. the end inside when done.
E

C
D

B E
A

13. The first level is complete. 14. Fold the next flap down. 15. ...and the next flap...

E E
F F

G
16. ...and the next flap... 17. ...and the final flap, folding 18. Completed model.
over the first flap, under the next,
and out the other side.
The Martian Bouncing Spider
copyright 1997 by Perry Bailey

1. fold and unfold paper diagonaly in half both ways then 2. Blintz fold again the center
blintz fold in all the corner to the center. Then unfold completely and
turn the model over.

3. Fold the raw edge up to the top crease, then 4. Fold the raw edge up to the first crease,
unfold and reapeat on other 3 sides. then unfold. Repeat on other 3 sides.
Turn the model over.
5. Make a really large rabbits ear, then unfold and 6. This is all of the folds after step 5, from here
repeat on the other thre corners. we go to the crease pattern to fold this into
a long armed windmill.

7. Collapse the model in to a long armed 8. The model should have collapsed into
pinwheel. a large pinwheel type shape. Note
the small square in the center of the
model remains flat through out the
collapse. In the next diagram you
will see only 1 arm shown.
10. Note that the bottom most preliminary base
9. Notice creases on the arm of the model, is four layers, put two layers to each side,
the next step is to use these creses to the other folds will be only 1 layer each.
fold each arm into 3 preliminary base
each one opposite to the one before.

11. Three layers of preliminary


bases on on top the other.

12. This is an enlarged view of the


leg we just folded. Now we fold
half of a bird base.

13. Fold another half of a bird base,


but in the opposite direction.
14. Fold the final half 15. Finished view of one leg.
of a bird base in
opposite direction of
the previous one.

16. Repeat steps 9


through 15 on all
legs.
17. Now to finish your martian bouncing
Odd note here if you feel the need to improve your spider, grab the tip of each leg one at
spiders bounce some careful wet folding at the end, a time and gently pull in out till the
or glue if you want to hold the square part of his middle of the leg becomes tube like.
body together, or just use stiff paper like I do and
it should work just fine! Perry

18. Each leg will pull out like this. Finished!!!! now tap the x and
watch him bounce! With practice
you can even dribble your spider.
$ Butterfly
Copyright 1998-99 Stephen Hecht. All Rights Reserved
A dollar bill makes a model 55mm long with a 65mm wingspan. For your first attempt, begin with a 3x7
rectangle larger than a dollar bill.

1. Begin black side up. 2. Crease halfway, 3. Soft mountain-fold


Valley-crease, the horizontal making a mark. on 45-degree line.
not too sharply. Turn over.

4. Pinch where mark from 5. Use mark from previous 6. Use the 2 existing
step 2 hits edge. Unfold. step to make this valley- creases to add 3 more.
fold. Unfold.

7. Pinch halfway marks 8. Mountain in half.


where indicated. 9. Crease and unfold.

10. Crease and unfold, bisecting. 11. Reverse-fold, in-and-out. 12. Reverse-fold.
Crease from previous step will
align with vertical crease.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

13. Pleat top layer on 14. Reverse-fold, following 15. Pleat top layer, softly
existing creases. the hidden edge. Unfold to on the dotted line.
step 13.

17. Bisect angle. Softly on 18. Creases exist as shown.


16. Follow hidden vertical edge. dotted line. Unfold to step 13.
Softly on dotted line.

13-19 fudge
here
A B

19. Collapse on the creases. 20. Note that “A” does not 21. Pleat. Mountain-fold is the
First close up the mountain- reach corner. Repeat 13- existing half-line. For the valley,
fold triangle, pinching the tiny 19 on rear flap. bring the 1/4-mark to lie under
new valley-fold. Then flatten “B”. The dotted line is a hidden
to form mountain-fold “A”. mountain-fold caused by shifting
paper.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

22. Note shifted creases in


fudged area. It needn’t be 23. Close-up of right edge. 24. Fold and unfold (bisection),
precise, it will be hidden later. Fold and unfold to hidden edge aligning previous crease with
Repeat 21 behind. (hold model up to the light). hidden edge.

25. Reverse-fold, in-and-out. 26. Reverse-fold. These 27. Fold and pinch, where
steps are similar to 9-12. limited by most recent
Turn over. reverse-fold.

29. Push from behind and create


a new mountain-crease linking 30. Begin to flatten by pinching
the base of the reverse-folds to where shown. Swing the
28. Undo the reverse-fold standing edge to the right.
from step 26. Then spread the pinch mark of step 27.
the area towards the right.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

D
C

align

32. Swivel. The upper crease 33. Wrap top layer around to
31. To flatten, first align bottom partially exists. Use it to start
edges. Then flatten “C”, then the inside. Reverse-fold
the swivel and locate the end corner, noting the bisected
flatten “D”. Careful of tearing of the vertical crease.
due to imprecision. angle.

34. Reverse-fold hidden 35. Crease and unfold. 36. Reverse the two creases
corner, bisecting. Then Lower crease bisects. Upper just made and add the tiny
unfold it. crease aligns vertical edges. mountain-fold, pushing edge
towards the left (model not flat).

23-39

37. Still pushing towards the left, 38. Model is flat again. Swivel 39. Curve the tip towards you
also push in at the tiny valley-fold, on existing creases and tuck a bit. Helps keep together.
swinging the point down to align between layers. Repeat steps 23-39 on the
with edge “C”. other wing.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

41. “E” is the mark made in step 40-41


40. Entire model again. 7. First make the long mountain-
folds. Then make the left valley 42. Thus. Repeat 40-41 on
Spread upper layers a bit. other side. Then open model
(an exact bisection). Then make
the right valley (not an exact out.
bisection), closing up the model.

43-44

43. Valley-fold, limited by the 45. Closed-sink central ridge


folds of step 41. If you have 44. Valley to previous crease
and unfold. Repeat 43-44 on the halfway.
been accurate, it will hit the
bottom corner. Unfold. left. Close up the model again.

47. Reform valley-folds from


46. Tuck into sink, creasing 44, then valley folds from 43. 48. Mountain to shape wing.
sharply. Repeat behind. Close up model, adding new Reverse-fold at overlaps to help
Then open model again. mountain folds. secure. Repeat behind. Bottom
half is now done.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

50. Lift the single-ply 51. Reverse-fold the small


49. Top of model. Closed sink “reverse-fold”, exposing the corner, and close up the model.
(limited by paper at right). Then underside of the sink. This distributes the layers of
lift wing. the sink more evenly.

52. Squash the flap lifted in 53. Squash again. 54. Wrap raw edge to the
step 50, on existing creases. inside.

49-55

55. Tuck long flap into 56. Like so. Repeat 49-55
sunken pocket. Mountain- 57. Double-rabbit-ear the point
on other wing. to form antenna. Repeat
fold to shape wing. Reverse-
fold at overlap to help secure. behind. Distribute layers evenly.
$ Butterfly (continued)
Copyright 1998-99 Stephen Hecht. All Rights Reserved

58. Curl antenna. Fold wings, 59. Finished.


not too sharply, where limited by
body. Repeat behind.
Buck The Bunny
By Perry Bailey c 1998/1999
1
3
2
1 1 1

Take a dollar bill or a piece of paper


ONE
Reverse fold the entire bill out
around the same dimensions, fold it 1 1 side of the WB base.
in half the long way, then unfold.
I am using a dollar bill, starting front Make a Water bomb base while folding
side up crease it then turn it over. model in half.

5
4 6

1
1
Inside reverse fold the length Reverse fold in both corners,
of the bill back from about the (one to a side). Reverse fold the bottom flap up
half way mark of the top or bottom to form front paws, Make a Rabbits
of the WB base. ear fold on each side of the head.

7 8
Body not shown
head and front
Body not shown only here.
head and front
only here. Still in enlarged mode, Reverse fold
the front to make a nose, the top part
of the nose will co-operated if you force
it to, much like a small child or an ex-
spouse. Do an uneven double rabbits
This is shown enlarge to make ear fold along the lines shown to finish
it possible to see the fold lines. the ears. Then we shrink the picture
Squash down the ears, on both back down.
sides.

9 1/3 1/3 1/3 10

11
1
1/3 1/3 1/3
Now crimp fold the rear part of the bill We make an uneven rabbits ear
You should come out to get excess paper up inside of
from about 1/3 from the front on top, something like this.
to about 1/3 from the back on the bottom. the model, do both sides.
Now we need to work
inside the model so
the next view is interior
of the model.
12

13

This is how it should look after our thinning


the model out with the preceding fold. Now
do a double inside reverse fold to form the
haunches.
Swivel fold up the legs
14 on each side. I used the
back of the bill to give
you helpful reference points.

15

Crimp fold the head downwards, so it


is even on both sides. Then open up
the model to lock the head in to place.
(See next diagram)

16 This is inside the model and magnified, to lock the


head in to place just use a simple valley fold on the
tip of the crimped material. Then you are done!

Just for continuity here is the finished model


still in the attitude you started with.

While I designed it to sit up, it


can go on all fours.

With any luck at all your rabbits will all look a little
It just might tend to have the different, each time you make it! Almost all the
nose a little close to the ground. folds can be altered to make each bunny unique.
Dollar Bill Animal
Model Created and Diagrammed by A. Anselmo 12/93
anselmo@thermsa.eng.sunysb.edu

1) Prelimary base 2) You will get 3) Take one flap 4) Fold downwards. 5) Unfold steps 3
at top of bill, fold this. from base and fold and 4, and squash
lengthwise as well. upwards. the fold to get...

6) this. 7) Bring the tip at 8) You will get this. 9) After step 8, 10) Repeat steps
A upwards, as in Fold the top half you should have 3-9 on the other
the bird base. of this structure this. side.
down.

14) Valley 15) The basic


fold along the model. You can
middle. make fore legs and
hind legs by the
simple folds, as
11) Flip the 12) Fold the 13) Fold the
shown.
model over. top edges of the bottom of the
paper to the center. model up.
Dollar Bill Stand-Up Butterfly
Model Created and Diagrammed by A. Anselmo 5/94
anselmo@thermsa.eng.sunysb.edu

1) Mark the center of the bill 2) Flip the model over, and
with a valley fold, and then fold the small corners so that
fold diagonally to this mark. the remaining paper can be
tucked into the model.

4) Mountain fold the right hand 5) this. Valley


3) Now, fold those flaps
side of the model so you get... fold in the middle,
into the model.
where shown.

6) Mountain fold along


the heavy lines.

7) The model will now


be able to stand on a flat
surface.
A Butterfly for Alice Gray by Michael LaFosse c '92

Intermediate Fold from a small sheet of duo paper. Try varying the proportions in
steps 4 & 11 to create variations. A 5" square produces a 3 1/2" model.

Diagrammed by J.C . Nolan - Sept.'94


B-Wing Starfighter © James B. Raasch III, 12/14/97
1) 2) 3)

Begin with a bird base, colored side out, and Fold the triangular peak all the way down. Fold tip ‘A’ to tip ‘B’. Unfold.
fold the front flap all the way up. Turn the
model over. Note that no shading is shown
because there are no color changes, and it
makes some of the folds easier to see.

4) 5) 6)

Fold crease ‘A’ to crease ‘B’. Fold the top flap up along the existing Fold the triangular peak all the way up.
crease. This will become the cockpit.

Page 1 of 6
B-Wing Starfighter © James B. Raasch III, 12/14/97
7) 8) 9)

Fold the bottom flap all the way up. This will Fold the wing flap down, about half way Squash the sides of the wing flap so that the
become the main wing between the crease you just made and the edges are vertical. Again, the exact amount
edge formed from creasing the top flap. is not important, but try to line up the
The exact amount is not important. intersection of the top of the horizontal
creases and the cockpit flap with the vertical
crease. The intersection is hidden in the
diagram.

10) 11) 12)

Fold the triangular peak down at the crease Fold the model in half along the vertical axis Squash-fold the top flap up and to the left.
you made in step 8. from right to left. Repeat on the flap on the back. These will

Page 2 of 6
B-Wing Starfighter © James B. Raasch III, 12/14/97

13) 14) 15)

Petal fold the s-foil right. Repeat behind. Fold the flap up and to the left along a 45
0 Unfold the fold on the left side that was
line. Repeat behind. made when you made the petal-fold in step
13. Repeat behind.

16) 17) 18)

Fold the front half of the s-foil back along Fold the flap up along the horizontal. Fold the s-foil down as far as you can. This
the centerline, and tuck it under the top Repeat behind. crease will be horizontal, and will fall along
sheet of paper. Repeat behind. the edge of the engine pod. Repeat behind.

Page 3 of 6
B-Wing Starfighter © James B. Raasch III, 12/14/97
19) 20) 21)

Inside-reverse fold the tip of the s-foil to Outside-reverse fold the end of the main Finish forming the main wing by folding this
make the wingtip cannon. If you treat the wing to make the main wing cannon. flap inside the body. The midpoint of the
flap you folded inside in step 17 as one side, 450 line made by the outside-reverse fold
and do the reverse between that flap and makes the bottom endpoint of the crease.
the single sheet, you will end up with the The exact position, however, is not
bottom of the cannon white. Repeat behind. important, as long as it looks good. Repeat
behind.

22) 23) 24)

Fold the tip of the cockpit flap down to the Squash the flap up and to the left. Fold the flap over as far as you can to the
bottom horizontal crease. right.

Page 4 of 6
B-Wing Starfighter © James B. Raasch III, 12/14/97

25) 26) 27)

Fold the lower half of the flap up. Fold the tip down to the crease that formed Fold the tip to the vertical edge and unfold.
in the last step. Repeat behind.

28) 29) 30)

Fold the flap down along the crease made in Fold the tip of the nose in along the crease Fold the back of the engine pod into the
step 26. Repeat behind. made in step 28. body. Repeat behind.

Page 5 of 6
B-Wing Starfighter © James B. Raasch III, 12/14/97

31)

Fold the s-foils up to a horizontal position,


and your B-Wing is ready to fly.

The completed B-Wing. This is a pretty crude isometric view, but hey, I don't do this for a living. There are two things I am unhappy with; the S-
Foils should be below the engine pod, and the model is so thick that it needs a locking mechanism. Maybe those items will get fixed in a future
revision (i.e., when I have more time).

Page 6 of 6
C3PO

1 2 3

4 6
5

1/3

Valley fold, see step 5 for


exact positioning

7 8 9

1/2

1/3
1/4

10 11 12

1/4

13 14 15

Unfold to step 13

© R.Glynn August 1999


C3PO
16 17 18

Refold step 12 incorporating a crimp


to form the top of the mouth unfold again, then refold
Add another crease just below incorporating a crimp to form the
the crease from step 14 bottom half of the mouth

19 20 21

Rabbit ear

22
23 24

Model will not lie flat from now on


Squash fold

25 26 27

Inside reverse fold Repeat steps 22-26 on the left side

28 29 30

Sink the corners to form two Make the top of the head Lock the top of the head
ovals rounder with a mountain fold, round
the sides of the head

© R.Glynn August 1999


A circled number step number on the diagrams means there are written instructions for that step. Please
read them before folding. The folding sequence seems very mathematical. In reality most location points
are not that critical: It’s just a way of minimizing free folding.

6. Fold the bisector. Step 7 indicates the position of the endpoint.


8. Crimp on an existing valleyfold. The mountainfold starts at the endpoint of that valley and Step 9 indic-
ates its angle. Avoid creating the bottom border.
10. Mountain fold starting at A, nearly parallel to Y but widening slightly towards the top. Endpoint C is
just a fraction higher than B.
11. Make a tiny mark with your fingernail in the centre of the point.
12. Fold the bisector, starting from the mark in 11. Fold only the bottom third of the point.
16. Fold the point so that its edge crosses the circled point.
19. & 20. Rearrange existing folds on one layer of paper only.
21. Pinch both layers of paper at the indicated spots and move your hands together, curving the paper in
between (make a bump, not a hollow.) The top point should open out and move down.
24. Twist the top point to the front, wringing the cat’s neck.
40. Side view. Pull apart the two layers of the ears.
43. Gently curve the ears, the paper wants to do this anyway.
44. Curved ‘eyebrows’. Practice this in a separate sheet first.
45. Inside reverse fold. Don’t fold the edges, only curves here.
47. Side view. Get rid of the point by folding it up into the head.
56. Make sure flap A is folded into the tail.
59. Run your thumbnail along the tail furrow and extend it, curving upwards.
61. Gently curve back the paper along the dotted lines.

The final model will need a support to stand.

Copyright c 1996 Herman van Goubergen, all rights reserved.


PDF version 1999 by Sebastian Marius Kirsch <skirsch@t-online.de>.
Distribution for noncommercial purposes is free. Please contact the author
if you want to use this model for commercial purposes.
Gato

J. Aníbal Voyer

1
2
3

4 Base Pez
5

7 Repetir 4 y 5
6 al otro lado
8
9

10
11

12
13

14
15

16 17
18 Repetir del 15 19
al 17

21
20

22 23

25
24

27
28
26
29
30

31

32

33

34 Dar volumen a la 35 El paso de la cola solo


cabeza y al cuerpo se puede plegar si se ha dado
volumen al cuerpo
36 Adelgazar la barriga
del gato
37

38
39
Catamaran Maarten van Gelder  1987 May

11 12 Fold tip of 13 And again


foresail between
both layers.

1 2

3 4

14

5 6 7 The right half becomes the


double boat. The left half
is only folded double.

8 9 10
Caterpillar Maarten van Gelder  1984 Dec
DC B
Use a strip of paper 8 x 1 (24 x 3 inch or 20 x 2.5 inch will do), DC
both sides same color. Shorter than 8 x 1 is possible, but not as nice. BA
You may first try with a strip of 3 x 1. The diagrams are drawn as if folded of
a 3 x 1 strip. Only the finished model is drawn as if folded from a 8 x 1 strip.

S
SRQ X Y
P AQ
PX

9 Unfold front flap. See 10, 11 and also 10


finished model for position of
points P, Q, R and S

1 2
DC
B

3 4 11 12 Only upper flap; don’t push flat


Point S swivels automatically

5 6 S

13 Fold the flaps back to 14 Outside reverse fold


diagram 10 and repeat
11-13 on the right side
DC
BA

XY X Y
TSR TSR
QP QP

7 Reverse fold 8 Reverse fold: all tips 15 Outside reverse fold 16 17


whole length
18 19 Repeat 13 and 14 20

21 22 Fold head down


Reverse fold in ’nose’
Coat Created by Marc Vigo Anglada
June 1995

2. Reverse folds.
1. Start with a square paper.
Valley fold the top fourth

4. Reverse folds.
3. Sink the top vertex.

5. The result should look 6. Valley folds. The sleeves


like this. Turn the model over. fold straightforward.

(i)
(i)

(ii)

(iii)
(ii)

8. (i) Valley folds. 9. Finished coat.


7. (i) and (ii) Mountain
(ii) Outside reverse fold.
fold behind.
(iii) Fold inside.
’95
Columbine for Renate
by Kalei Anne Lundberg
copyright 1999
Columbine (Aquilegia) is a hardy pereneial belonging to the Buttercup Family. It is beautifully colored; Frequently the center,
outfacing petals, and spurs are different colors. This model was inspired by Guido Gazzera’s spurless Aquilegia model and is
dedicated to my cousin Renate, who first introduced me to this wonderful flower. The diagrams are for personal use only.
Please contact me at klunder@mnsinc.com to obtain permissionfor any other use. Enjoy.
Note: Some of the diagrams are flexed in order to indicate several
layers of paper or one corner open to show interior folding details.
All folds should be as accurate as possible.

1. Precrease pattern. Collapse into a windmill base. 2. Squash fold the four corners.

3. Fold and unfold the 4. Inside reverse along creases. 5. Petal fold outward all 4 corners as shown
flaps to thier center line, in the upper right hand corner. Circled corner
open to show interior detail. The raw edges
should butt tightly together. Some minor
adjustment might be necessary.
turn model over.

Columbine for Renate -- page 1 of 3


7. Narrow the points by folding
6. Fold the corners to center. the edges to their center line, 8. Fold and unfold to center. Then
Allowing the points underneath spread squashing the top. inside reverse along the crease.
to flip to the top.

11. Open the model and sink the


10. Spread squash the four center section. The sink line should
9. Collapse model bringing points corners, like a frog base. be almost but not quite even with
together like a bird base. Circled the folded up section from step 8.
area shows the interior detail of Make sure that the blintzed paper
step 8. underneath is folded into the sink
as well. This is a bit cumbersome

13. Open out the petals. Sharpen


12. a. Inside reverse the the crease on the spurs after they 14. Slight indication of top and side view.
four points. b. fold the swing downward. Now on to the leaves...
corners as close (6" paper will yield a flower approx. 2.5"
in diameter and are very
nice made from multi- colored papers.)

Columbine for Renate -- page2 of 3


Stretched Bird Base Clover

3. Pull the inside flaps out stretching


2. Inside reverse fold the four flaps. the model so that the center
pops upward.

1. Precrease pattern. Collapse


into Preliminary Fold.

4. Fold the two flaps down while 5. Squash fold the two flaps.
pushing the center point up and
inside.

6. Fold and unfold the three top points 7. Fold bottom point up
and then inside reverse along crease. to the back and turn the
model over.

8. Rabbit ear the point.


9. Squash the rabbit ear. 10. Fold model in half. 11. Fold and unfold top
leaf repeat behind to
give definition.
Glue wrapped floral wire into the squash fold of the clover. Attach 3
clovers together, one at tip and 2 side by side to make leaf. Glue
wrapped floral wire to the inside of the flower head and wrap leaf to
stem with floral tape. Hope you had fun. Columbine for Renate -- page 3 of 3
FANTASY MASK Matt Slayton
diagrams Alex Barber
1994

1 2

start white side up petal fold top flap


preliminary base turn model over

3 4

fold flaps to center squash flaps open


5 6

1 1

turn model over fold the flaps in the order shown

8 fold flaps behind to make horns

pleat top layer


to forn nose

sqush the points


to form eyes
10 11

round the chin

fold over the bottom


flap for the chin

12 13

fold the model in half swivel the nose out

14 15

open the model out


and keep the nose
pointing up
On the Water, Under Water
by Herman van Goubergen

1
2
3
Use a square of blue foil. The paper is white side up in step 7. The final moulding will be difficult if you
don’t use foil. Fix a flock/shoal on a sheet of transparent plastic (acetate, glass, . . . ) with small pieces of
sticky tape. Small sizes work sell: I cut up one 15×15 cm square to make 4 birds/fish.

Copyright c 1995–1996 Herman van Goubergen, all rights reserved.


PDF version 1999 by Sebastian Marius Kirsch <skirsch@t-online.de>.
Distribution for noncommercial purposes is free. Please contact the author
if you want to use this model for commercial purposes.

4
Shark Tooth
Matt Slayton • Diagrams Alex Barber • 1995

1 2

Precrease - the horizontal creases are


thirds. The bottom third is only a pinch.

3 4

Squash fold the flap.


Make a small reverse fold at the top while
mountain folding the model in half.
The model will not lie flat after this step.

5 6

Petal fold to lock.

1
7 8

Round the edges along the top of the tooth


and crimp the edges.

2
Making Letter Sized Proportion Rectangle from Square
Method I

A 1/2
C C
1/4

(1) Fold A to B (2) Mark point C at (3) Cut along horizontal line
intersection through point C

Method II
47x60 rectangle

1.3% difference from


letter size proportion
(8.5x11)

(4) Completed paper

(1) (2) Bisect angle again

A A A
C C
C

(3) Bisect AB to get C D E D F E


F
(5) Make crease passing
A (4) Bisect DE to get F C and E

C A

G C
G 0.1% difference
from letter size
proportion

D F E
(6) Crease passing AF; G F E
is the intersection of AF &
(7) Cut along vertical line (8) Completed
CE
through point G

También podría gustarte