Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Natural Gas - From Wellhead to Burner Tip > Business Overview > Natural Gas Regulations > Environm ent & Technology > Focus on LNG > Focus on Jobs > Natural Gas Quiz
Source: EIA
www.naturalgas.org/overview/unconvent_ng_resource.asp
1/3
acidizing. However, these techniques are also very costly. Like all unconventional natural gas, the economic incentive must be there to incite companies to extract this costly gas instead of more easily obtainable, conventional natural gas. Tight gas makes up a significant portion of the nation's natural gas resource base, with the Source: EIA Energy Information Administration (EIA) estimating that, as of January 1, 2000, 253.83 Tcf of technically recoverable deep natural gas exists in the U.S. This represents over 21 percent of the total recoverable natural gas in the United States, and represents an extremely important portion of natural gas resources. Shale Gas Natural gas can also exist in shale deposits, which formed 350 million of years ago. Shale is a very fine-grained sedimentary rock, which is easily breakable into thin, parallel layers. It is a very soft rock, but it does not disintegrate when it becomes wet. These shales can contain natural gas, usually when two thick, black shale deposits sandwich a thinner area of shale. Because of some of the properties of these shales, the extraction of natural gas from shale formations is more difficult and perhaps more expensive than that of conventional natural gas. Shale basins are scattered across the United States. As of November 2008, FERC estimated there were 742 Tcf of technically recoverable shale gas resources in the United States, more than triple the 215 Tcf the agency had estimated two years earlier. Shale represents a large and growing share of the United States recoverable resource base. For additional information on shale natural gas please visit our shale section. Coalbed Methane Coal, another fossil fuel, is formed underground under similar geologic conditions as natural gas and oil. These coal deposits are commonly found as seams that run underground, and are mined by digging into the seam and removing the coal. Many coal seams also contain natural gas, either within the seam itself or the surrounding rock. This coalbed methane is trapped underground, and is generally not released into the atmosphere until coal mining activities unleash it. Historically, coalbed methane has been considered a nuisance in the coal mining industry. Once a mine is built, and coal is extracted, the methane contained in the SSource: EIA seam usually leaks out into the coal mine itself. This poses a safety threat, as too high a concentration of methane in the well creates dangerous conditions for coal miners. In the past, the methane that accumulated in a coal mine was intentionally vented into the atmosphere. Today, however, coalbed methane has become a popular unconventional form of natural gas. This methane can be extracted and injected into natural gas pipelines for resale, used as an industrial feedstock, or used for heating and electricity generation. In June 2009, the Potential Gas Committee estimated that 163 Tcf of technically recoverable coalbed methane existed in the United States, which made up 7.8 percent of the total natural gas resource base. What was once a by-product of the coal industry is becoming an increasingly important source of methane and natural gas. For more information on coalbed methane, visit the Environmental Protection Agency. Geopressurized Zones Geopressurized zones are natural underground formations that are under unusually high pressure for their depth. These areas are formed by layers of clay that are deposited and compacted very quickly on top of more porous, absorbent material such as sand or silt. Water and natural gas that are present in this clay are squeezed out by the rapid compression of the clay, and enter the more porous sand or silt deposits. The natural gas, due to the compression of the clay, is deposited in this sand or silt under very high pressure (hence the term 'geopressure'). In addition to having these properties, geopressurized zones are typically located at great depths, usually 10,000-25,000 feet below the surface of the earth. The combination of all these factors makes the extraction of natural gas in geopressurized zones quite complicated. However, of all of the unconventional sources of natural gas, geopressurized zones are estimated to hold the greatest amount of gas. Most of the geopressurized natural gas in the U.S. is located in the Gulf Coast region. The amount of natural gas in these geopressurized zones is uncertain. However, experts estimate that anywhere from 5,000 to 49,000 Tcf of natural gas may exist in these areas. Given that current technically recoverable resources are around 1,100 Tcf, geopressurized zones offer an incredible opportunity for increasing
www.naturalgas.org/overview/unconvent_ng_resource.asp 2/3
resources are around 1,100 Tcf, geopressurized zones offer an incredible opportunity for increasing the nation's natural gas supply. Methane Hydrates Methane hydrates are the most recent form of unconventional natural gas to be discovered and researched. These interesting formations are made up of a lattice of frozen water, which forms a sort of 'cage' around molecules of methane. These hydrates look like melting snow and were first discovered in permafrost regions of the Arctic. However, research into methane hydrates has revealed that they may be much more plentiful than first expected. Estimates range anywhere from 7,000 Tcf to over 73,000 Tcf. In fact, the USGS estimates that methane hydrates may contain more organic carbon than the world's coal, oil, and conventional natural gas - combined. However, research into methane hydrates is still in its infancy. It is not known what kind of effects the extraction of methane hydrates may have on the natural carbon cycle or on the environment. Unconventional natural gas constitutes a large proportion of the natural gas that is left to be extracted in North America, and is playing an ever-increasing role in supplementing the nation's natural gas supply. As technology advances and new methods of extracting and using this natural gas are developed, the resource potential of unconventional natural gas is enormous.
| Natural Gas - From the Wellhead... | Business Overview | Natural Gas Regulations | Environment & Technology | Focus on LNG
2004 - 2011 - All rights reserved - NaturalGas.org
www.naturalgas.org/overview/unconvent_ng_resource.asp
3/3