Documentos de Académico
Documentos de Profesional
Documentos de Cultura
PREFLIGHT A/C documents Landing gear control Cowl flaps Master switch Magnetos All Avionics All Electric Mixture control Flight controls Master switch Landing gear lights Fuel indication Fuel selector Pitot tube Pitot heat External lights Stall warning All electric Master switch
NORMAL PROCEDURES
aboard+checked check down position check open check off check off check off check off check idle cut off check free on check 3 green check quantity fuller tank cover removed on - check (outside) on - check (outside) check (outside) off off
BE 33 BONANZA
PREFLIGHT cont. Chocks Tow bar Nose gear Engine oil Air intakes Propeller+spinner Fuel sump LH fuel quantity LH fuel drain LH main gear LH wing+aileron+flap Tail section Static vents RH wing+aileron+flap RH main gear RH fuel drain RH fuel quantity Antennas baggage door
NORMAL PROCEDURES
check removed check removed check check quantity (9-11 qts) check unobstructed check drain check visual drain check check check check unobstructed check check drain check visual check undamaged latch securely
Page 1 of 8
2006-07-17
Page 2 of 8
2006-07-17
BE 33 BONANZA
NORMAL PROCEDURES
adjust fasten check in
BE 33 BONANZA
BEFORE TAXI Avionic master Warning lights Autopilot Electric Wing flaps Altimeters HSI+RMI Heading bug Avionics TAXI Taxi light Brakes Flight instruments Fuel selector
NORMAL PROCEDURES
on press test press test on as required full travel then up 2x set+compare check heading set RWY heading set for departure
BEFORE STARTING ENGINE Seats Seat belts and shoulder harness Circuit breakers STARTING ENGINE Master switch Alternator Rotating beacon Mixture Propeller control Throttle control Electric fuel pump Throttle Magnetos Propeller area Starter Throttle Oil pressure Warning lights
on on on full rich full forward full open on (fuel flow peak) inch open on check clear engage 1000 RPM check green arc check off
Page 3 of 8
2006-07-17
Page 4 of 8
2006-07-17
BE 33 BONANZA
NORMAL PROCEDURES
BE 33 BONANZA
LINE UP / TAKE OFF Transponder Runway Pitot heat Landing light Strobe lights Time Throttle full open 71 / 77 / 96 KIAS Positive ROC CLIMB Climb power Gear Wing flaps Cowl flaps Mixture Landing light CRUISE Altimeters Power Mixture Cowl flaps
NORMAL PROCEDURES
BEFORE TAKE OFF Taxi light Mixture control Propeller control Cowl flaps Fuel selector Engine instruments Throttle control Propeller control Magnetos Alternate air Ammeter Gyro pressure Engine instruments Throttle control Wing flaps Flight controls Elevator trim Doors and windows (front+aft) Seat belts Departure briefing T/O briefing
off check full rich check full RPM check open check fuller tank check green arc 1700 RPM 3x exercise check 150/50 then both check check pitot heat on/off check check green arc 1000 RPM check up position check free set check latched tighten completed completed
25MP/2500 RPM check up position check up position check open rich / set fuel flow off
Page 5 of 8
2006-07-17
Page 6 of 8
2006-07-17
BE 33 BONANZA
DESCENT Seat belts Cowl flaps Fuel quantity Power Mixture APPROACH Fuel selector Landing light Mixture control Altimeters Approach briefing
NORMAL PROCEDURES
BE 33 BONANZA
AFTER LANDING Time Transponder Wing flaps Cowl flaps Pitot heat Strobe lights Landing light / Taxi light PARKING Avionics master All electric (except beacon) Throttle Mixture control Magnetos Alternator Rotating beacon Master switch
NORMAL PROCEDURES
FINAL APPROACH Gear below 154 KIAS Brakes Wing flaps below 154 KIAS Gear Mixture control Propeller control
down / 3 green checked intermediate position check 3 green check full forward full forward
off off close idle cut off off off off off
Rotation Best Angle Best Rate Cruise climb Gear down Flaps intermediate Manoeuvering
Page 7 of 8
2006-07-17
Page 8 of 8
2006-07-17