Documentos de Académico
Documentos de Profesional
Documentos de Cultura
968XTP
Z (inward X
swinging)
Axis X Y Z
Y (outward
swinging)
DOO
Open
Frame
Door
Align edges
TAM PE SCR R EW
Magnet Assembly
Align Edges
Area to be protected
DO
OR
Frame
Door
Supplemental Information
Wiring
The normal condition of the 968XTP is when it is reporting secure, energized by the magnet. The two white tamper wires will be closed when the tamper switch is in secure condition. The tamper contacts should be connected to a 24 hour circuit to trigger an alarm any time the switch module is tampered with. Maximum contact ratings depend on the voltage put through the switch. They are 250 mA at 12 V or less and 125 mA at 24 V. The tamper circuit can handle a maximum of 1 Amp.
Black Green Red White White Common Normally Closed (NC) Normally Open (NO) Tamper NC Tamper NC
Green Red Black White White NC NO COM Tamper NC Tamper NC
Notes
To minimize tamper potential, the 968XTP should be installed inside the perimeter being protected. The switch assembly / magnet combination is designed to have a nominal gap of 0.45 (11.4 mm). The system will go into alarm condition if the gap is approximately 0.63 (16.0 mm) and greater, or approximately 0.27 (6.9 mm) or less. To account for system tolerances, a 7/16 1/16 (11.1 mm 1.6 mm) gap has been specified in these instructions. The minimum make gap is 0.53 (13.5 mm). Approvals/listings: cULus listed EN 50131-1:2006 and EN 50131-2-6:2008 Security Grade 3 Environmental Class II; Certified by VdS. Suitable for connection to an EN 60950 Class II Limited Power Source in European Installations. For any additional information, please refer to our Website, www.honeywell.com/security/emea/hscdownload or contact: Honeywell Security Group Quality Assurance Dept. Newhouse Industrial Estate Tel: +44(0)1698 738200 Motherwell Email: UK64Sales@Honeywell.com Lanarkshire ML1 5SB United Kingdom
5-051-649-00F4
P/N 5-051-649-00F 9/11 Rev A