Documentos de Académico
Documentos de Profesional
Documentos de Cultura
7—2005
ISO 603-7:1999
AS 4524.7—2005
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
COPYRIGHT
© Standards Australia
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Published by Standards Australia GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 6499 1
ii
PREFACE
This Standard was prepared by the Standards Australia Committee ME-033, Abrasives, to supersede,
AS/NZS 4524.7:1998, Bonded abrasive products—Dimensions, Part 7: Grinding wheels for off-hand
grinding.
This Standard is identical with and has been reproduced from ISO 603-7:1999, Bonded abrasive
products—Dimensions, Part 7: Grinding wheels for manually guided grinding.
The objective of this Standard is to provide manufacturers and users of bonded abrasive products with
details of minimum dimensional requirements for these products.
The objective of this revision is to adopt the current edition of ISO 603-7.
As this Standard is reproduced from an international Standard, the following applies:
(a) Its number appears on the cover and title page while the International Standard number appears
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Contents Page
1 Scope ........................................................................................................................................................................ 1
3 Dimensions............................................................................................................................................................... 2
4 Designation .............................................................................................................................................................. 5
5 Specifications........................................................................................................................................................... 6
5.2 Balancing............................................................................................................................................................... 6
Bibliography ................................................................................................................................................................ 7
© ISO 1999
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic
or mechanical, including photocopying and microfilm, without permission in writing from the publisher.
International Organization for Standardization
Case postale 56 • CH-1211 Genève 20 • Switzerland
Internet iso@iso.ch
Printed in Switzerland
ii
This is a free preview. Purchase the entire publication at the link below: