Está en la página 1de 1

Features Applications

NT
IA
■ DC to 2 GHz ■ High power RF transmission

PL
M ■ Flanged model
CO
S
oH

■ Low VSWR
*R

CHF3020CBF Series Power RF Terminations / Resistors

General Specifications Characteristic Curve


Substrate ......................................... Beo
Resistive Film ........................ Thick Film 100
Tab ..................................................... Ag

% of Rated Power
Cover Substrate ...........................AL203 80
Mounting Flange......... Cu plated with Ni 60
Resistance
Termination.................... 50 ohms only 40

Resistor ...See Resistance Value Table 20


Tolerance ....................................... ±5 %
Packaging..........................100 pcs./box 0
-55 0 100 150
Absolute Ratings
Heat Sink Temperature (°C)
Power ............... See Rated Power Table
Frequency..................................2.0 GHz Product Dimensions
VSWR ............................. 1.30 Maximum 3.7
Capacitance .................................0.8 pF MAX.
(0.146)

1.0 6.5 5.08 2.57 2.54


Resistance Value Table (0.039) (0.256) (0.200) (0.101) (0.100)

R Value (Ohms) Code “L” TERMINATION


1 TAB
50 500 (Available only in 50 ohm)
100 101 6.35
7.62
(0.300)
200 201 (0.250)
250 251
300 301
2.54 3.0 2.54 1.57
(0.100) (0.118) (0.062) 0.1
Rated Power DIA.
(0.100)
(0.004)

Version Power (W) DIMENSIONS = MILLIMETERS 3.7


(INCHES) MAX.
C 10 (0.146)
2.57
D 25 1.0 6.5 5.08
(0.101)
2.54
(0.039) (0.256) (0.200) (0.100)

How to Order
“R” RESISTOR
2 TABS 7.62
CHF 3020 C B F 500 L 6.35
(0.300)
(0.250)
Model
Size
Version
2.54 3.0 2.54 1.57
C = 10 W 0.1
(0.100) (0.118) (0.062)
D = 25 W (0.100)
(0.004)
DIA.
Substrate
Mount Mounting High Power Devices
F = Flange
Value (see Resistance Value Table) The mounting surface must be flat to less
Termination/Resistor Tabs (1 for Termination, 2 for Resistors)
Function than 0.0254 mm (0.001 ”) and devoid of
L = Termination (50 ohms only) scratches or burrs. The underside of the
R = Resistor flange should be brushed with thermal
grease prior to being fastened to the heat
sink with mounting screws. The thermal Circuit Board
grease will fill any air gaps and help to
keep a good thermal contact. Heat Sink/Ground Plane Flange

Pre-tin the tab prior to installation. Position the tab over the circuit and solder in place.

Ensure that the temperature on the surface of the flange does not exceed 110 ˚C when
running at 100 % of load. If the temperature increases then derate the power.

REV. 09/09
*RoHS Directive 2002/95/EC Jan 27 2003 including Annex.
Specifications are subject to change without notice.
Customers should verify actual device performance in their specific applications

También podría gustarte