Está en la página 1de 18

Componente Hardware Passport

Familia 7k
Familia 15k
Bus
LED-Status
Ersteller: Enrico Lock, TTO-SW
Datum: 12.06.16

7k-Passport (Seria 7480)


ATMAS types of cards used in the 7k-Passport

Control Processor = CP
Slot 0 and Slot 15
(each CP has one HDD)

Function Processor = FP
Slot 1- Slot 14

32pE1Msa (Multi service access)


32pE1MsaStp
2pOC3SmAtm2 (optische STM1-Ports)
2pSTM1eAtm
2pSTM1elCh (Channelized-Karte)

Power
the shelf can be equipped with three power supplies

Fan
screenshot von der MDM

12.06.16

Seite 2

Enrico Lock, TTO-SW

Trafficcards (FPs) des 7k-Passports

2pStm1eAtm (NTNQ90)
Services:
ATM, IP over ATM, Trunk

2pStm1eCh (NTNQ96)

32pMsaE1Stp (NTNQ72)

Services:
SDH-Multiplex, ATM, CES,
IMA, Trunk, IP over ATM

Sevices:
FrameRelay, CES, ATM,
IMA, IP over FrameRelay, Trunk

2pOC3SmAtm2 (NTNQ66)
Services:
ATM, IP over ATM, Trunk

Bildquelle: Nortel Networks

12.06.16

Seite 3

Enrico Lock, TTO-SW

n+1 protection MSA-Karte

Termination Panel

main card

main card

spare card
Quelle Karten- und Panelgrafik : Nortel Networks

12.06.16

Seite 4

Enrico Lock, TTO-SW

1+1 protection STM1el-Karten


Schematic diagram for wiring of electrical equipment protection STM1 cards with termination panel.
Note the proper wiring of the control cable (dashed line).

Bildquelle: Nortel Networks

12.06.16

Seite 5

Enrico Lock, TTO-SW

3+1 protection for 2pSTM1eAtm and 2pSTM1elCh


Termination
Panel

top row are the coax


jacks for port 0? bottom
row are the coax
connectors for Port 1

Control

Liniile punctate reprezinta


cablu TX/RX bidirectional

spare card

main card (mainA)

12.06.16

Seite 6

main card (mainB)

Enrico Lock, TTO-SW

Quelle Karten : Nortel Networks


Quelle Panel: Enrico Lock

12.06.16

Seite 7

Enrico Lock, TTO-SW

15k-Passport
Tipuri de cadrui prezente in PP 15K

Control Processor = CP
Slot 0 and Slot 1
(each CP has one HDD)

CPeE
Function Processor = FP
Slot 2- Slot 15

16pOC3PosAtm
4pOC3SmIrAtm
BIP (Breaker Interface Panel)
Power (-48V / bis 100A)
Consists of two BIM (Breaker Interface Module) for a 15k shelf?
Or 4 BIMs 15k for 2-Shelf 19'' rack.

screenshot von der MDM

12.06.16

Seite 8

Enrico Lock, TTO-SW

15k-Passport

Fan
two Fabrics
= replaceable bus

external clock input


MAC-Address Card
Power Interface moduls

12.06.16

Seite 9

Enrico Lock, TTO-SW

Trafficcards (FPs) des 15k-Passport


16pOC3PosAtm
(NTHW44 oder NTHW48)
Sevices:
ATM, IP over ATM, Trunk

Note:
Is an SDH port is failed,
may be faulty SFP.

Bildquelle: Nortel Networks

12.06.16

Seite 10

Enrico Lock, TTO-SW

12.06.16

Seite 11

Enrico Lock, TTO-SW

Overview of Interfaces and Protection


Card

Passport Type

Interfaces

Protection *

CP

7k-PP und 15k-PP

Ethernet
V.24

1+1

32pE1Msa

7k-PP

32 E1-Port

n+1

32pE1MsaStp

7k-PP

32 E1-Port
1 Stm1-Port
(Opt. / unstructured)

n+1 (fr E1en)


keine (fr STM1)

2pOC3SmAtm2

7k-PP

2 Stm1-Port Opt
(Opt. / unstructured)

keine

2pSTM1eAtm

7k-PP

2 Stm1-Port
(elect. / unstructured)

n+1 bis max. 3+1


(bisher 1+1)

2pSTM1eCh

7k-PP

2 Stm1-Port
(elect. / structured)

n+1 bis max. 3+1


(bisher 1+1)

16pOC3PosAtm

15k-PP

16 Stm1-Ports
(Opt. / unstructured)

keine

*The column "Protection" describes the capabilities of the hardware protection. ?


It is also possible to protect circuits by means of software,? for example,
over optical lines LAPS (linear Automatic Protection Switching)

12.06.16

Seite 12

Enrico Lock, TTO-SW

Hardware Printouts
sde230> d sh card/* insertedCardType, cardType
==|============================================
|
inserted
cardType
|
CardType
==|=====================(1)=========(2)========
A|SDE230 Shelf Card/0 CP
CP
B|SDE230 Shelf Card/1 2pSTM1eCh
2pSTM1eCh
C|SDE230 Shelf Card/2 none
none
D|SDE230 Shelf Card/3 2pSTM1eCh
2pSTM1eCh
E|SDE230 Shelf Card/4 none
none
F|SDE230 Shelf Card/5 2pSTM1eCh
2pSTM1eCh
G|SDE230 Shelf Card/6 none
none
H|SDE230 Shelf Card/7 2pSTM1eCh
none
I|SDE230 Shelf Card/8 none
none
J|SDE230 Shelf Card/9 32pE1Msa
32pE1Msa
K|SDE230 Shelf Card/10 none
none
L|SDE230 Shelf Card/11 2pOC3SmAtm2 2pOC3SmAtm2
M|SDE230 Shelf Card/12 none
2pOC3SmAtm2
N|SDE230 Shelf Card/13 2pOC3SmAtm2 2pOC3SmAtm2
O|SDE230 Shelf Card/14 2pOC3SmAtm2 2pOC3SmAtm2
P|SDE230 Shelf Card/15 CP
CP
==|============================================
16 ok
Jan 30/06 16:38:39

State when the card is inserted but


not yet configured

State when the card is not


recognized by the system (eg card
has locked up or is defective)

Meaning of the parameters: insertedCardType indicates the type recognized by the Passport Card
cardType shows the configured card type

SDE229> d -no sh text


Shelf
commentText
= MSC Kornwestheim (15k)
ok
2006-01-30 16:53:25.52

12.06.16

Seite 13

Enrico Lock, TTO-SW

Comment text with the location of


the passport

Meaning of the LED states


7k

LED

LED Status

State

OFF

Card is dead

RED

Card performs self-test


Defective condition longer than 30 sec

Slowly flashing
red

Card waiting for loading the software

Rapidly flashing
red

Card loads Software

Slowly flashing
green

Card is loaded but not activated


(eg after a lock card "lock sh card / 1")

Blinking green
rapidly

Card is in Sparingmode

Permanent green

Card is active and working

Permanent amber

Hardware of the card is o.k. But? Card can not work

15k

12.06.16

Seite 14

Enrico Lock, TTO-SW

Bus
The bus in the Passport is designed with redundancy
Traffic is distributed on the two buses, ie if the sum of the utilization of bus / x and bus / y is> 100%, then the fault of a bus
traffic affecting
sde246> d sh bus/*
For 7k Passport family of the bus "bus" is and is
==|=======================================================
#|
SDE246
SDE246
inextricably linked to the shelf. ? If the bus is
|
Shelf
Bus/x
Shelf Bus/y
broken needs to be replaced, the entire shelf

s/
y

B
u

s/
x

In the 15k Passport family consists of two bus


"Fabric Card" s, which can be replaced separately
from each other

12.06.16

Seite 15

Enrico Lock, TTO-SW

==|============================(A)===========(B)==========
1|adminState
unlocked
unlocked
2|operationalState
enabled
enabled
3|usageState
active
active
4|availabilityStatus
5|proceduralStatus
6|controlStatus
7|alarmStatus
8|standbyStatus
notSet
notSet
9|unknownStatus
false
false
10|busTapStatus 0
ok
ok
11|busTapStatus 1
ok
ok
12|busTapStatus 2
none
none
13|busTapStatus 3
ok
ok
14|busTapStatus 4
none
none
15|busTapStatus 5
ok
ok
~~~
25|busTapStatus 15
ok
ok
26|clockSource
activeCP
activeCP
27|clockSourceStatus activeCP ok
ok
28|clockSourceStatus alternate notApplicable notApplicable
29|utilization
2 %
4 %
==|=======================================================
2 ok
Jan 08/08 16:00:39

restart und reset


restart sh card/7
LED Status:

red permanently
Slowly flashing green
green flashing quickly

- The card performs a self-test (inference from the LED state)


- Software reloaded

reset sh card/7
LED Status:

red permanently
flashing red
green flashing quickly
Slowly flashing green

Reset the hardware


Perform a self-test cards
Reloading the software

12.06.16

Seite 16

Enrico Lock, TTO-SW

Instructiuni importante
reset sh
reboot the passport (traffic affecting)

reset sh card/9
reboot der card in Slot 9 (traffic affecting)

d lp/* main,spare,activ
shows the Protection Configuration: Main card protection card and which card is
active

switch lp/3
switch the card in slot 3 on the protection card; run the command again to switch
back, if switching is not executable "switch-force lp / 3"

lock force sh card/3


Lock card (traffic affecting; LED cards - slowly flashing green)

12.06.16

Seite 17

Enrico Lock, TTO-SW

Exemple (lock)
sde246> lock -force sh card/1
Shelf Card/1
ok

2008-05-13 15:52:34.49

sde246> d sh card/1 state


==|===============================
#|
SDE246
|
Shelf Card/1
==|===================(A)=========
1|adminState
locked
2|operationalState
enabled
3|usageState
idle
4|availabilityStatus
5|proceduralStatus
6|controlStatus
7|alarmStatus
major
8|standbyStatus
notSet
9|unknownStatus
false
==|===============================
1 ok
May 13/08 15:52:39

The standbyStatus
attribute indicates whether
the card is processing
traffic or is standby
12.06.16

Seite 18

Card belongs to a 1 +1 protection


Card was locked (see admin state)
Release the card by unlock

sde246> unlock sh card/1


Shelf Card/1
ok

2008-05-13 15:53:19.52

sde246> d sh card/1 state


==|================================
#|
SDE246
|
Shelf Card/1
==|===================(A)=========
1|adminState
unlocked
2|operationalState
enabled
3|usageState
active
4|availabilityStatus
5|proceduralStatus
6|controlStatus
7|alarmStatus
8|standbyStatus
hotStandby
9|unknownStatus
false
==|===============================
1 ok
May 13/08 15:53:31

Enrico Lock, TTO-SW

sde246> d sh card/3 state


==|====================================
#|
SDE246
|
Shelf Card/3
==|===================(A)==============
1|adminState
unlocked
2|operationalState
enabled
3|usageState
active
4|availabilityStatus
5|proceduralStatus
6|controlStatus
7|alarmStatus
8|standbyStatus
providingService
9|unknownStatus
false
==|====================================
1 ok
May 13/08 15:57:46

También podría gustarte