Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Connector-by-label
Connector-far-from-label
OBD female
connector has the
same pinout as the
vehicle.
Normally comes
with Galletto 1260.
14.
15.
16.
17.
Steps:
1. Connect Galletto 1260 cable to OBD port, and USB.
2. Prepare Galletto software.
3. Power up the ECU.
4. Wait 5 seconds, remove the grey wire from pin20.
5. ECU is now in boot mode.
6. Download the ECU firmware, make a backup. (Will
be needed later)
7. Power down the ECU.
8. Open the binary in your favourite hex editor.
9. Change 0x25 value to 0xDA at 0x08C5.
10. Change 0xFF value to 0x4A at 0x0C601.
11. Upload the modified binary to the ECU.
12. Disassemble the bench, and put the ECU back in car.
13. Turn key to MAR, do not start.
Wire color
yellow
Red
Black
Grey
ECU connector
By-the-label
By-the-label
By-the-label
Far-from-label
ECU pin(s)
2
17,18,33,49,51
5,22,ECU-body
20
ODB pin
K-LINE (7)
+12 (16)
GND (4)
GND (4)