Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Users Guide
42-7012
Tape / Ribbon
45 RPM Adapter
2. Remove the tape and ribbon from the belt, and stretch the belt
around the drive motor spindle. Do not twist the belt.
3. Slowly rotate the turntable six or seven times, then check the belt.
If it is not secure, reposition it and repeat. If the belt slips under the
platter, do not attempt to remove the platter. Take it to your local
RadioShack store for assistance.
4. Set the LINE OUT/PHONO OUT switch. If you
are uncertain which output your connecting device
requires, refer to its users guide.
5. Place the rubber mat, ridges down, on the platter.
PHONO OUT
For low-level phono output.
LINE OUT
For line-level output.
In this Package
Turntable
45 RPM Adapter
Users Guide
04/04
LEFT/RIGHT
AUDIO
Connect to
audio input.
AC Cord
Connect to
standard
AC outlet.
1. Open the dust cover and place the record on the turntable. To play a 45 RPM record, place the 45 RPM adapter over the center spindle.
GROUND WIRE
Connect to
ground terminal.
FAQ
A dirty or worn stylus causes rough, distorted sound and could damage
your records.
Caution: Do not touch the stylus while cleaning or installing it. If the
stylus gets dirty or dusty, use a soft brush to gently clean it. You can
order a replacement stylus assembly AT3600LAX through your local
RadioShack store.
To replace the stylus:
7XUQRII\RXUUHFHLYHUDPSOLHU
2. Gently grasp the stylus assemblys sides and pull.
3. Gently snap the new stylus assembly into place.
Care
6SHFLFDWLRQV
To protect the stylus from damage, replace the stylus cover when not
using the turntable.
Check the power cord and the AC outlet for a power problem.
Lift the rubber matt on the platter and check the rubber drive belt. It
may have slipped or broken.
Keep the turntable away from dust and dirt. Wipe it with a damp cloth
occasionally to keep it looking new.
Turntable Platter
Type................................................................................................................. Plastic
Outer Diameter ..................................................................11.81 Inches (300 mm)
Drive System ............................................................................................Belt Drive
Motor Type ................................................................................................ DC Motor
Turntable Type............................................................................Automatic Return
Rotation Speed ........................................................2-Speed 33 1/3 and 45 RPM)
Tone Arm
Type..............................................................................................Dynamic Balance
Effective Length ...................................................................7.68 Inches (195 mm)
Overhang ....................................................................................0.56 Inch (15 mm)
Tracking Error......................................................................................Less Than 4
Cartridge
Output Voltage ..............................................................2.5 mv at 1 kHz (PHONO)
.................................................................................... 200 mv at 1 kHz (LINE OUT)
Frequency Response ..........................................................................2020,000 Hz
Channel Separation (1 kHz) ...................................................... More Than 15 dB
Load Resistance.............................................................. 47 kohm (PHONO OUT)
Tracking Force.................................................................................. 3.5 1.0 Gram
Stylus
Tip ...................................................................................................Diamond Stylus
Replacement ......................................................................................... AT3600LAX
General
Signal-to-Noise Ratio (DIN-B) .................................................................. > 50 dB
Wow and Flutter (JIS WARMS) at 3 kHz .................................................< 0.25%
Power Source ........................................................................... AC 120 Volts 60 Hz
Power Consumption.................................................................................... 3 Watts
Dimensions (HWD) ................. 3.81 x 14.25 x 13.94 Inches (98 x 360 x 349 mm)
Weight ...................................................................................... 5 lbs 4 oz (2.38 kgs)
&KHFNWKHUHFHLYHUDPSOLHUYROXPH
Check the turntable connections.
Do not place the turntable on top of components that get hot. Use and
store the turntable only in normal temperature environments.
Check if the turntable is set to PHONO OUT but connected to linelevel input jacks. Set the turntable to LINE OUT.
Replace the stylus.
CAUTION
WARNING: 7RUHGXFHWKHULVNRIUH
or sh ock h a za rd , d o n ot exp ose th is
p rod u ct to ra in or m oistu re
CAUTION: T O R E D U C E T H E R I S K O F E L E C T R I C S H O C K , D O N O T
R E M O V E T H E C O V E R O R B A C K . N O U S E R -S E R V I C E A B L E P A R T S I N S I D E .
R E F E R S E R V IC IN G TO Q U A L IF IE D P E R S O N N E L .
The lightning symbol is intended to alert you to the presence
of uninsulated, dangerous voltage within this products
HQFORVXUHWKDWPLJKWEHRIVXIFLHQWPDJQLWXGHWRFRQVWLWXWHD
risk of electric shock. Do not open the products case.
The turntable may be set to LINE OUT and the turntable is connected
to low-level phono input jacks. Set the turntable to PHONO OUT.
Why do I hear feedback from my turntable?
The turntable is picking up the sound pressure of vibrations from the
speakers. Reposition the turntable away from the speakers.
6SHFLFDWLRQVDUHVXEMHFWWRFKDQJHDQGLPSURYHPHQWZLWKRXWQRWLFH$FWXDO
SURGXFWPD\YDU\IURPWKHSURGXFWLPDJHVLQWKLVGRFXPHQW
42-7012
07A06
Printed in China