Documentos de Académico
Documentos de Profesional
Documentos de Cultura
BT-CSO
1. Symptom
Shortly after machine installation (up to 10kp), the inside of the transfer belt are
slightly damaged and the line appears to the sub-scan direction
(FD, belt conveyance direction) at the corresponding position on the image.
2. Cause
The inside of transfer belt is rubbed with the steel plate and shaft in the transfer
belt unit and damaged. The change of transfer conditions at the damaged part
appears as line on the image.
3. Countermeasure
To reduce the damage while conveying transfer belt:
1) Contact point of the steel plate with the transfer belt has been changed to roller type.
**A03UR7A300 Mouting Plate Assy
2) The shaft has been changed to rotational type with much smoother surface
**A03UB50400 Roller /Upper Assy
Roller /Upper Assy(A03UB50400)
4. Replacement procedure
Step 1
Step 2
Step 3
Step 4
Step 5
Step 6
Step 7
Remove 6 screws and remove the old type of Mouting Plate Assy.
Step 8
Step 9
Step 10
Step 11