HAMADA
Mechanical information
BAS82 series452 Series SERVICE MANUAL.
B452 SERIES MACHINE SERVICE MANUAL
Table of Contents --
1, Precautions on Installation and Operation of Machine:
[1] Installation environment (1) through (5).
[2] Power source
[3] Installation precaution
[4] Carrying in the machine
(1) Method of carrying in the machine:
[5] Leveling the machine
(1) Accuracy of level
(2) Method of leveling-
2. Trial operation:
[1] Wiring to the machine
(1) Wiring ofthe power supply
(2) Wiring to additional equipment
(vater circulation unit, decurler and compressor)
(@) Wiring to the ink key controler ~
(4) Wiring to the unit control box-
[21 Piping ~
(1) Piping to the water circulating system-
(Piping the compressor and decurler
[3] Checking the electrical
(1) Checking the phase of the power supply
(2) Inspection and adjustment of supply voltage
(3) Inspection of control voltage-~
(4) Inspection of sensitivity of double sheet detection sensor-
(5) Checking the operation of safety cover and safety bar
1s
{5] Seting the pump pressu
[6] Lubrication and idling-
(1) Lubrication after installation ~
2) dling
{71 Inspection at delivery and installation
{81 Periodic
3. Referencedegree for each adjustment:
[1] Set the point of reference to 45 deg.
(21 Timing table
4. Jigs for gripper opening adjustment
[1] Bearing for No.1, No.2 impression cylinder and No.3 transfer eylinder gripper
{2} Cam for adjustment of No.2 and No. transfer cylinder grippers
ting the compressor pressure:
inspection sheet (Maintenance sheet)
[3] Adjustment screw for gripper shaft adjustment
[4] Lever positioning block gauge for swing gripper opening —
[5] Cam positioning gauge for swing gripper opening